LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2019 >> S450 Base >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Collision - Side Wall (222 Chassis) >> Side Wall Body Repair >> Install C-Pillar Strut - Ar63.20-P-0500-09LFS

Install C-Pillar Strut - Ar63.20-P-0500-09LFS

Model 222 

with code Z07 (B7 armoring on special protection version) 

IMPORTANT The following steps are shown on the left side of the vehicle and must be accomplished analogously on the right side in the event of damage.

  1. Install C-pillar strut (1), fit and fix in place.
  2. Mark position of rivet holes on rear center section.

    IMPORTANT The distance between the rivet holes and the outer edge should be at least 10 mm.

    IMPORTANTDimensions: 

    a = approx. 17 mm

    b = approx. 18 mm

  3. Drill Ø 6.7 mm rivet holes on C-pillar strut (1) (area C).
  4. Coat insides of riveted joints with zinc dust paint (area C).

    After removing C-pillar strut (1) and deburring rivet holes.

    G15399964Courtesy of MERCEDES-BENZ USA
  5. Drill Ø 6.7 mm rivet holes on C-pillar strut (1) and countersink (area D).

    Only if a riveter for punching and flow form rivets is not used for installation

    NOTES Countersink rivet holes to create level surface when riveting Otherwise the rear fender cannot be installed correctly.

  6. Drill Ø 6.7 mm rivet holes on C-pillar strut (1) and countersink (area E and F).

    IMPORTANT Drill rivet hole in center of flange The distance between the rivet hole and the outer edge should be at least 10 mm (area F).

  7. Remove C-pillar strut (1).
  8. Drill rivet holes in C-pillar strut (1) and deburr on body on both sides.
    G15399978Courtesy of MERCEDES-BENZ USA
  9. Apply 2-component adhesive to body in crosshatched areas.

    IMPORTANT Observe pretreatment of bonding surfaces. Observe manufacturer's specifications for drying and processing time of adhesive.

    G15399979Courtesy of MERCEDES-BENZ USA
  10. Install C-pillar strut (1), fit and fix in place.
  11. Rivet C-pillar strut (1) with Ø 6.4x12 rivets (areas I and O).
  12. Rivet C-pillar strut (1) with Ø 6.4x14 countersunk head rivets (area J).

    IMPORTANT Flow form rivets with a clamping range of up to 3.5 mm "A1" can also be used, if a riveter for self-piercing and flow-form rivets is used for installation.

    G15399980Courtesy of MERCEDES-BENZ USA
  13. C-pillar strut (1) POLARIZATION RESISTANCE SINGLE-ROW SPOT WELD (areas K).
  14. Clean welding areas no longer accessible after installing rear fender with zinc dust paint.
G15399981Courtesy of MERCEDES-BENZ USA