Remove/Install Headliner - AR68.30-P-4300FR
Model 257
Shown on model 257 with code 811 (Advanced Sound System) and with code 414 (Sliding sunroof)
Shown on model 257 with code 811 (Advanced Sound System)
Shown on model 257 with code 811 (Advanced Sound System) and with code 414 (Sliding sunroof)
| Remove/install | |||
| 1 | Remove windshield | AR67.10-P-1700FR | |
| 2 | Completely open sliding roof lining on sliding roof | Model 257 with code 414 (Sliding sunroof) |
|
| 3 | Completely open roller sun blind on rear window | Model 257 with code 540 (Electric sunblind for rear window) |
|
| 4 | Remove inside rearview mirror | AR68.40-P-0001FR | |
| 5 | Remove sun visors (2) | AR68.60-P-5480FR | |
| 6 | Remove front grab handle (4) and rear grab handle (5) | AR68.30-P-4330FR | |
| 7 | Remove upper B-pillar paneling (6) | AR68.30-P-4700FR | |
| 8 | Remove C-pillar paneling (7) and lay down to side with seat belt installed | AR68.30-P-4490FR | |
| 9 | Disconnect electrical connector (8) | Model 257 with code 811 (Advanced sound system) |
|
| 10 | Slightly fold back foam material and disconnect electrical connector (11) | ||
| 11 | Remove edge guard from body flange in area of roof lining (1) | ||
| 12 | Press catch hooks (arrows) together and unclip headliner (1) from front roof frame | ||
| 13 | Loosen headliner (1) on left and right on sliding roof frame | Model 257 with code 414 (Sliding sunroof) |
Fig 1 |
| 14 | Detach roof lining (1) from roof bow at brackets (10) | ||
| 15 | Push roof lining (1) toward rear until guide hooks (9) are unhooked from rear roof frame and place roof lining (1) down in vehicle | ||
| 16 | Remove roof lining (1) from vehicle through window cutout in windshield | Do not bend headliner (1) excessively. Otherwise the headliner (1) can kink and be damaged. |
|
| 17 | Make sure that all of the soundproofing on the headliner (1) is properly attached and in good condition. | Model 257 with code 460 (Canada version) Model 257 with code 494 (US version) If the headliner (1) is reused. If a problem arises ↓ Replace the affected soundproofing on the headliner (1). |
|
| 18 | Prepare new headliner (1) for installation | When replacing roof paneling (1). | AR68.30-P-4305-16FR |
| Adhesive tape roll, non-woven Tesa tape, 50 meters, 50 mm wide | *BR00.45-Z-1144-02A | ||
| 19 | Install in the reverse order |
REPAIR MATERIALS
| Number | Designation | Order number |
|---|---|---|
| BR00.45-Z-1144-02A | Adhesive tape roll, non-woven Tesa tape, 50 meters, 50 mm wide | A 008 989 50 85 09 |