LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2018 >> S450 Base >> Repair and Diagnosis >> Collision >> Structural >> Collision - Body Construction (222 Chassis) >> Body Construction >> Remove And Install UNDERGUARD - Ar61.40-P-1001LFS

Remove And Install UNDERGUARD - Ar61.40-P-1001LFS

Model 222 

with code Z07 (B7 armoring on special protection version) 

G15370561Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
1 Remove fuse 4 from fuse box I, rear right wheel well    
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform.
Raise vehicle with vehicle lift
Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. AS00.00-Z-0010-01A
3 Secure center armor plate (2) against falling down and detach from underfloor IMPORTANT Helper required.  
    TORQUE SPECIFICATION Screw/bolt, armor plate to armor plate/undercarriage *BA61.40-P-1003-01D 
4 Lower center armor plate (2) until threaded connections on extinguishing agent line (6) are accessible Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
 
5 Disconnect left and right extinguishing agent lines (6) at threaded connections Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
 
    TORQUE SPECIFICATION Threaded connections for extinguishing agent lines *BA86.10-P-1003-01B 
6 Remove center armor plate (2) IMPORTANT Helper required.  
7 Remove center spray nozzles (4) from center armor plate (2) Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system) When replacing center armor plate (2).
 
    TORQUE SPECIFICATION Bolt, nozzle holder to armor plate *BA86.10-P-1004-01B 
8 Secure left front armor plate (1) or night front armor plate (10) against falling down and remove TORQUE SPECIFICATION Screw/bolt, armor plate to armor plate/undercarriage *BA61.40-P-1003-01D 
9 Remove front spray nozzle (5) from left front armor plate (1) and right front armor plate (10) Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system) When replacing left front armor plate (1) and right front armor plate (10).
 
    TORQUE SPECIFICATION Bolt, nozzle holder to armor plate *BA86.10-P-1004-01B 
10 Remove rear fire extinguishing agent temperature sensor (8) from rear armor plate (3) and secure with wire or cable tie on underfloor Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
INSTALLATION NOTES Ensure that electrical wiring harness is routed without tension to rear fire extinguishing agent temperature sensor (8) and without pinching o chafing.
Otherwise a malfunction of the fire extinguishing system may occur.
 
11 Secure rear armor plate (3) against falling down    
12 Lower rear armor plate (3) until nozzle holder of rear spray nozzles (7) is accessible Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
 
    TORQUE SPECIFICATION Screw/bolt, armor plate to armor plate/undercarriage *BA61.40-P-1003-01D 
13 Remove nozzle holder of rear spray nozzles (7) from rear armor plate (3) Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
 
    TORQUE SPECIFICATION Bolt, nozzle holder to armor plate *BA86.10-P-1004-01B 
14 Secure nozzle holder of rear spray nozzles (7) on underfloor with wire or cable tie Model 222.1/9
with code Z07 (B7 armoring on special protection version)
with code Z21 (Fire extinguishing system)
 
15 Remove rear armor plate (3) IMPORTANT Helper required.  
16 Install in the reverse order    
UNDERRIDE GUARD

Number Designation Model 222 with code Z07 (B7 armoring on special protection version)
BA61.40-P-1003-01D Screw/bolt, armor plate to armor plate/undercarriage M6 Nm 6
M8 Nm 27
FIRE EXTINGUISHING SYSTEM

Number Designation MODEL 222.1/9 with CODE Z07 and CODE Z21
BA86.10-P-1003-01B Threaded connections for extinguishing agent lines Size 14 Nm 12
Size 17 Nm -
Size 19 Nm -
FIRE EXTINGUISHING SYSTEM

Number Designation MODEL 222.1/9
with CODE Z07 and CODE Z21
BA86.10-P-1004-01B Bolt, nozzle holder to armor plate Nm 23