Check condition of battery - AR54.10-P-1129RK
MODEL 231
| Risk of injury caused by fingers being jammed or pinched when removing, installing or aligning hoods, doors, trunk lid/rear-end door or sliding roof. | No parts of the body or limbs should be within the operating area when the components are moving. | AS00.00-Z-0011-01A | |
| Risk of explosion from explosive gas. Risk of poisoning and caustic burns from swallowing battery electrolyte. Risk of injury through burns to skin and eyes from battery acid or when handling damaged lead-acid batteries | No fires, sparks, open flames or smoking. Wear acid-resistant gloves, clothing and glasses. Only pour battery acid into suitable and appropriately marked containers. |
AS54.10-Z-0001-01A | |
| Notes on battery | AH54.10-P-0001-01A | ||
| Notes on sensor system for trunk lid opening/closing | AH80.61-P-0001-01A | ||
| Notes on AGM battery | AH54.10-P-0002-01A | ||
| Remove | |||
| 1 | Open luggage compartment lid | ||
| 2 | Remove luggage compartment paneling | ||
| 3 | Remove spare tire well panel | ||
| Check | |||
| 4 | Visually inspect on-board electrical system battery (G1) for external leakage | ↓ Remove/install battery |
AR54.10-P-0005RK |
| 5 | Check on-board electrical system battery (G1) 000 588 02 19 00 Battery tester | AR54.10-P-1129-01A | |
| WS54.00-N-3006B | |||
| Battery capacity 95 Ah VRLA | *BE54.10-P-1015-01A | ||
| 6 | Reduce increased voltage after charging process | With an on-board electrical system battery (G1) which has been disconnected from the on-board electrical system. If the "Surface voltage detected" message is shown in the display of the Midtronics battery tester and test equipment. | AR54.10-P-1129-03A |
| 000 588 03 19 00 Load tester | WS15.00-P-0027B | ||
| 7 | Charge on-board electrical system battery (G1) | With the test code "Charge and check" on the Midtronics battery tester and test equipment. |
AR54.10-P-1130RK |
| Install | |||
| 8 | Install panel for spare wheel well | ||
| 9 | Install trunk floor trim panel | ||
| 10 | Close trunk lid |
TEST AND ADJUSTMENT VALUES FOR BATTERY
| Number | Designation | Model all | |||
|---|---|---|---|---|---|
| BE54.10-P-1015-01A | Battery capacity 95 Ah VRLA | Cold cranking amps | As per EN | A | 850 |