LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2017 >> GLS350d >> Repair and Diagnosis >> Suspension >> Suspension Control Systems >> Suspension - 166 Chassis 1 Of 2 >> Testing & Repair >> Replace Air Suspension Compressor Elastomer Bearing - AR32.22-P-2011TX

Replace Air Suspension Compressor Elastomer Bearing - AR32.22-P-2011TX

Model 164, 166 

with code 489 (AIRMATIC Dual Control/semi-active air suspension) 

Model 219 

with code 489 (AIRMATIC Dual Control/semi-active air suspension) 

Model 292 

with code 489 (AIRMATIC Dual Control/semi-active air suspension) 

Fig 1: Air Suspension Compressor Elastomer Bearing Components Location - Model 166 With Code 489 (Shown On Model 219)
G14135905Courtesy of MERCEDES-BENZ USA

Shown on model 219 

REMOVING Remove     
1 Remove AIRMATIC compressor unit (A9/1) Model 164, 166, 292
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2001GZ 
    Model 219.3
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2001TX
2 Remove bracket for compressor Model 219.3
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2009TX 
MEASURING Measure     
3 Using vernier caliper, measure thread diameter of a threaded rod (1) at bracket (2) for AIRMATIC compressor unit (A91) IMPORTANT Replace the bracket (2) with thread M5.  
4 Push stop buffer (3a) out of eyelet on AIRMATIC compressor unit (A9/1) NOTES Always replace the stop buffer (3a) and attaching parts of the AIRMATIC compressor unit (A9/1).
Otherwise knocking and thumping noises can occur if the stop buffers (3a) and attaching parts are reused.
 
INSTALLING Install     
5 Insert stop buffer (3a) into eyelet on AIRMATIC compressor unit (A9/1) IMPORTANT The raised section of the stop buffer (3a) must face downwards. The groove of the stop buffer (3a) must engage all round its circumference into the eyelet on the AIRMATIC compressor unit (A9/1).  
6 Fit shim (3b) onto stop buffer (3a)    
7 Slide stop buffer (3c) onto protective sleeve (3d) IMPORTANT The outer lip of the stop buffer (3c) must enclose the washer of the protective sleeve (3d) around its total circumference (arrow).  
8 Mount push spring (3e) onto protective sleeve (3d) IMPORTANT The push spring (3e) is centered by a demolding on the stop buffer (3c).  
9 Install bracket for compressor Model 219.3
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2009TX 
10 Install AIRMATIC compressor unit (A9/1) Model 164, 166, 292
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2001GZ 
    Model 219.3
with code 489 (AIRMATIC Dual Control/semi-active air suspension)
AR32.22-P-2001TX