Check Condition Of Battery - AR54.10-P-1129GZ
MODEL 164, 166, 292
MODIFICATION NOTES
| 14.06.2017 | Condition extended | Operation step 3 |
| Risk of injury caused by contact with battery gel when handling damaged lead-gel batteries | No fires, sparks, open flames or smoking. Wear acid-resistant gloves, clothing and glasses. | AS54.10-Z-0001-02A | |
| Risk of explosion from explosive gas. Risk of poisoning and caustic burns from swallowing battery electrolyte. Risk of injury through burns to skin and eyes from battery acid or when handling damaged lead-acid batteries | No fires, sparks, open flames or smoking. Wear acid-resistant gloves, clothing and glasses. Only pour battery acid into suitable and appropriately marked containers. |
AS54.10-Z-0001-01A | |
| Notes on battery | AH54.10-P-0001-01A | ||
| Notes on AGM battery | AH54.10-P-0002-01A | ||
| Check | |||
| 1 | Perform visual inspection for external leakage | In the event of leakage ↓ Replace on-board electrical system battery. |
AR54.10-P-0005GZ |
| 2 | Check on-board electrical system battery | Cold cranking amps as per EN | AR54.10-P-1129-01A |
| Battery capacity 70 Ah VRLA | *BE54.10-P-1010-01A | ||
| Battery capacity 95 Ah VRLA | *BE54.10-P-1015-01A | ||
| Fig 2 | |||
| 3 | Reduce increased voltage after charging process | For an on-board electrical system battery that is disconnected from the on-board electrical system, and shows the message "Surface voltage detected" or test voltage greater than 12.8V in the display of the Midtronics battery/test equipment. | AR54.10-P-1129-03A |
| Fig 1 | |||
| 4 | Charge on-board electrical system battery | If test code "Charge and test" is shown on the Midtronics battery tester and analysis device MCR 717. |
AR54.10-P-1130GZ |
TEST AND ADJUSTMENT VALUES FOR BATTERY
| Number | Designation | Model all (4xWD, CAR, smart) | |||
|---|---|---|---|---|---|
| BE54.10-P-1010-01A | Battery capacity 70 Ah VRLA | Cold cranking amps | As per EN | A | 760 |
TEST AND ADJUSTMENT VALUES FOR BATTERY
| Number | Designation | Model all (4xWD, CAR, smart) | |||
|---|---|---|---|---|---|
| BE54.10-P-1015-01A | Battery capacity 95 Ah VRLA | Cold cranking amps | As per EN | A | 850 |