Remove/Install Oil Return Flow Line Of Turbocharger - AR09.40-P-6021CD
ENGINE 651 in MODEL 166, 172, 204, 207, 212, 218, 221
| Remove/install | |||
| Risk of death when touching components on vehicles with high-voltage on-board electrical system | Do not touch damaged or defective components and open lines of the high-voltage on-board electrical system. Persons who wear electronic implants (e.g. cardiac pacemakers) must not carry out any work on high-voltage on-board electrical systems. | AS54.00-Z-0001-01A | |
| Risk of death caused by vehicle slipping or toppling off of the lifting platform. | Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. | AS00.00-Z-0010-01A | |
| Risk of injury . Skin or eye injuries may result when handling hot or glowing objects. | Wear protective gloves, protective clothing and safety glasses, if necessary. | AS00.00-Z-0002-01A | |
| 1 | Remove power electronics with power distributor | MODEL 212.098/298 | AR08.10-P-0011EH |
| 2 | Detach ground line of on-board electrical system battery Notes on battery |
Model 166, 172, 204, 207, 212 (except 212.098/298), 218, 221 | AH54.10-P-0001-01A |
| MODEL 166 | AR54.10-P-0003GZ | ||
| MODEL 172 | AR54.10-P-0003W | ||
| MODEL 204 | AR54.10-P-0003CW | ||
| Model 207, 212 (except 212.098/298), 218 | AR54.10-P-0003EW | ||
| MODEL 221 |
AR54.10-P-0003SX | ||
| 3.1 | Remove underfloor paneling | MODEL 166 | AR61.30-P-1001GQ |
| 3.2 | Remove bottom sections of soundproofing | Model 172, 204.0/2/3, 207, 212 (except 212.098/298), 218 MODEL 172 |
AR94.30-P-5300W |
| Model 204.0/2/3, 207, 212 (except 212.098/298), 218 | AR94.30-P-5300EW | ||
| 3.3 | Detach lower engine compartment paneling | MODEL 204.9, 221 MODEL 204.9 |
AR61.20-P-1105CY |
| MODEL 221 | AR61.20-P-1105SX | ||
| 4 | Loosen alternator and place down to front | Model 166, 172, 204, 207, 212 (except 212.098/298), 218, 221 Engine 651 in model 166 |
AR15.40-P-5032GR |
| Model 172, 204, 207, 212 (except 212.098/298), 218, 221 | AR15.40-P-5032CD | ||
| 5 | Remove screw/bolts (1) and oil return line (2) | *BA09.40-P-1010-01P | |
| 6 | Install in the reverse order | ||
| 7 | Check engine oil level, correct if necessary | The engine oil level must lie between "Min" and "Max". Engine damage can occur otherwise. |
|
| Risk of accident from vehicle starting off by itself when engine running. Risk of injury (bruises and burns) resulting from working on the engine while it is being started or when it is running. | Secure vehicle to prevent it from starting off by itself. Wear buttoned-up and snug-fitting work clothes. Do not touch hot or rotating parts. | AS00.00-Z-0005-01A | |
| 8 | Carry out an engine test run and check the oil return line (2) for leaks |
TURBOCHARGER
| Number | Designation | Engine 651 | |
|---|---|---|---|
| BA09.40-P-1010-01P | Bolt, oil return line to crankcase/turbocharger | Nm | 9 |