LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2016 >> S550 Base >> Repair and Diagnosis >> Suspension >> Electronic Suspension >> Suspension - 222 Chassis >> Testing & Repair >> Remove/install compressor - AR32.22-P-2001LF

Remove/install compressor - AR32.22-P-2001LF

MODEL 217 

except code 487 (Active Body Control (ABC)) 

MODEL 222 

except code 487 (Active Body Control (ABC)) 

Shown on MODEL 222 

Fig 1: Compressor Remove/Install Components - Shown On Model 222
G11132319DANGERIMPORTANTREMOVINGINSTALLINGIMPORTANTSPECIAL TOOLIMPORTANTTORQUE SPECIFICATIONSPECIAL TOOLTORQUE SPECIFICATIONTORQUE SPECIFICATIONSPECIAL TOOLSPECIAL TOOLIMPORTANTTORQUE SPECIFICATIONREFER TO BASIC KNOWLEDGEIMPORTANTDANGERCourtesy of MERCEDES-BENZ USA
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. AS00.00-Z-0010-01A
IMPORTANT Notes on AIRmatic   AH32.22-P-1000-02LF
REMOVINGINSTALLING Remove/install     
1 Switch off ignition and remove transmitter key    
2 Remove front engine compartment paneling   AR61.20-P-1105LF
3 Detach left fender liner from bumper   AR88.10-P-1300LF
4 Unlock and disconnect electrical connectors (1, 2)    
5 Open clamp (3) and pull off air intake hose IMPORTANT Seal air intake hose with stop plug.
SPECIAL TOOL Record plug
Fig 3
6 Detach pressure line (4) from AIRmatic compressor (A9/1) IMPORTANT Seal the pressure line (4) with a stop plug.  
    TORQUE SPECIFICATION Pressure line to air compressor/valve block *BA32.22-P-1006-03F 
    SPECIAL TOOL Record plug Fig 3
    If the pressure line (4) is damaged:

Repair AIRmatic pressure line connection.
AR32.22-P-2001-02SX
    TORQUE SPECIFICATION Pressure line to central reservoir *BA32.22-P-1007-03F 
    TORQUE SPECIFICATION Pressure line to air compressor/valve block *BA32.22-P-1006-03F 
    Leak detection spray *BR00.45-Z-1002-03A 
    SPECIAL TOOL Socket wrench bit Fig 2
    SPECIAL TOOL Knife Fig 4
7 Unscrew nuts (5) and remove AIRmatic compressor (A9/1)    
IMPORTANT Notes on self-locking nuts and bolts   AH00.00-N-0001-01A
    TORQUE SPECIFICATION Nut, compressor mounting to bracket for air compressor *BA32.22-P-1004-03F 
8 Replace AIRmatic relay (K40/8kR) When replacing AIRmatic compressor (A9/1)  
REFER TO BASIC KNOWLEDGE Assignment of engine fuse and relay module IMPORTANT When replacing the AIRmatic compressor (A9/1), always replace the AIRmatic relay (K40/8kR) as its switching contacts may have been damaged previously. GF54.15-P-1256-32LF
9 Transfer bearings with brackets When replacing AIRmatic compressor (A9/1)  
10 Install in the reverse order    
11 Perform leak check   AR32.22-P-8100LF 
DANGER Risk of accident  from vehicle starting off by itself when engine running. Risk of injury  (bruises and burns) resulting from working on the engine while it is being started or when it is running. Secure vehicle to prevent it from starting off by itself. Wear closed and snug-fitting work clothes. Do not touch hot or rotating parts. AS00.00-Z-0005-01A
12 Perform engine test run and check AIRmatic for proper operation    
AIR SUSPENSION

Number Designation Model 217 Model 222
BA32.22-P-1004-03F Nut, compressor mounting to bracket for air compressor Nm 5 3
AIR SUSPENSION

Number Designation Model 217 Model 222
BA32.22-P-1006-03F Pressure line to air compressor/valve block Nm 3, 5 3, 5
AIR SUSPENSION

Number Designation Model 217 Model 222
BA32.22-P-1007-03F Pressure line to central reservoir Nm 5 5
Fig 2: Identifying Socket Wrench Bit (211 589 00 09 00)
G11132320Courtesy of MERCEDES-BENZ USA
Fig 3: Identifying Record Plug (129 589 00 91 00)
G11132321Courtesy of MERCEDES-BENZ USA
Fig 4: Identifying Knife (000 589 12 28 00)
G11132322Courtesy of MERCEDES-BENZ USA
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1002-03A Leak detection spray Christof Fischer GmbH