Check/replace water drain valve in steering gear - AR46.20-P-0005EW
MODEL 166, 218
MODEL 204, 207, 212 with CODE 211 (Direct-Steer system) MODEL 217
MODEL 222
MODEL 231 with CODE 211 (Direct-Steer system)
Shown on model 218
Shown on closed water drain valve
Shown on opened water drain valve
| Notes on self-locking nuts and bolts | AH00.00-N-0001-01A | ||
| Information on preventing damage to electronic components due to electrostatic discharge | AH54.00-P-0001-01A | ||
| Remove/install | |||
| 1.1 | Remove center section of the lower engine compartment paneling | MODEL 204.0/2/3., 207, 212, 218 with gasoline engine | |
| AR61.20-P-1105EW | |||
| 1.2 | Remove center engine compartment paneling | MODEL 231 with CODE 211 (Direct-Steer system) |
|
| AR61.20-P-1105RK | |||
| 1.3 | Remove center engine compartment paneling | MODEL 204 with CODE 211 (Direct-Steer system) |
|
| AR61.20-P-1105CY | |||
| 1.4 | Remove center engine compartment paneling | MODEL 217 MODEL 222 |
|
| AR61.20-P-1105LF | |||
| 1.5 | Remove center bottom section of soundproofing | MODEL 204.0/2/3, 207, 212, 218 with diesel engine | |
| AR94.30-P-5300EW | |||
| 1.6 | Remove corresponding underfloor paneling | MODEL 166 | |
| AR61.30-P-1001GQ | |||
| 2 | Remove bolts (1) and remove cover panel (2) | If installed MODEL 207, 212 with CODE 211 (Direct-Steer system) MODEL 218 |
*BA33.10-P-1005-01M |
| Check | |||
| 3 | Check water drain valve (4) for condition (open, closed) | If water drain valve (4) is open, check both boots for damage and check toothed rack for corrosion. ↓ Replace boot, replace water drain valve (4). |
|
| MODEL 166, 218 MODEL 204, 207, 212 with CODE 211 (Direct-Steer system) |
AR46.40-P-0400EW | ||
| MODEL 231 with CODE 211 (Direct-Steer system) |
AR46.40-P-0400RK | ||
| MODEL 217 MODEL 222 |
AR46.40-P-0400LF | ||
MODEL 217.364/378/384/385 MODEL 217.377/379/382/477/479/482 MODEL 222.004/032/057/077/082/104/123/157/162/163/165/176/177/179/182 MODEL 222.033/067/085/133/167/178/184/185 |
*BA46.20-P-1004-01P | ||
MODEL 204 (except 204.08/09/28/29/38/904/937/98/99) with CODE 211 (Direct-Steer system) MODEL 204.08/09/28/29/38/904/937/98/99 with CODE 211 (Direct-Steer system) MODEL 207 (except 207.388) with CODE 211 (Direct-Steer system) MODEL 207.388 with CODE 211 (Direct-Steer system) MODEL 212 (except 212.039/066/067/08/090/091/093/094/097/099/266/267/28/291/293/294/297/299) with CODE 211 (Direct-Steer system) MODEL 212.039/066/067/08/090/091/093/094/097/099/266/267/28/291/293/294/297/299 with CODE 211 (Direct-Steer system) MODEL 218 (except 218.367/368/391/393/394/967/968/991/993/994) MODEL 218.367/368/391/393/394/967/968/991/993/994 |
*BA46.20-P-1012-01N | ||
MODEL 166 MODEL 231 with CODE 211 (Direct-Steer system) |
*BA46.20-P-1003-01O | ||
| 4 | Install in the reverse order |
FRONT AXLE CARRIER
| Number | Designation | MODEL 207 | MODEL 212 | |
|---|---|---|---|---|
| BA33.10-P-1005-01M | Bolt, cover panel to front axle carrier | Nm | 55 | 55 |
FRONT AXLE CARRIER
| Number | Designation | MODEL 218 | |
|---|---|---|---|
| BA33.10-P-1005-01M | Bolt, cover panel to front axle carrier | Nm | 55 |
STEERING GEAR
| Number | Designation | MODEL 166 | MODEL 231 | |
|---|---|---|---|---|
| BA46.20-P-1003-01O | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 222 except 4MATIC | MODEL 222 with 4MATIC | |
|---|---|---|---|---|
| BA46.20-P-1004-01P | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 217 except 4MATIC | MODEL 217 with 4MATIC | |
|---|---|---|---|---|
| BA46.20-P-1004-01P | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 204 except 4MATIC, except 204.9 | MODEL 204 with 4MATIC, with MODEL 204.9 | |
|---|---|---|---|---|
| BA46.20-P-1012-01N | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 207 except 4MATIC | MODEL 207 with 4MATIC | |
|---|---|---|---|---|
| BA46.20-P-1012-01N | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 212 except 4MATIC | MODEL 212 with 4MATIC | |
|---|---|---|---|---|
| BA46.20-P-1012-01N | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |
STEERING GEAR
| Number | Designation | MODEL 218 except 4MATIC | MODEL 218 with 4MATIC | |
|---|---|---|---|---|
| BA46.20-P-1012-01N | Bolt, water drain valve to electrical rack-and-pinion steering | Nm | 20 | 20 |