Check Airmatic For Leaks - AR32.22-P-8100GZ
WARNING: This page does not describe the selected car, but rather 27 other vehicles, including the 2019 Mercedes-Benz GLE63 S AMG, 2019 Mercedes-Benz GLE63 AMG, 2019 Mercedes-Benz GLE43 AMG, 2019 Mercedes-Benz GLE400, and 2018 Mercedes-Benz GLE63 S AMG. However, it is still accessible from the selected car via links, so may be relevant.
MODEL 164, 166, 292 with CODE 489 (AIRMATIC)
Show on model 164.1
Shown on model 166.057
Shown on model 166.873
| Notes on AIRmatic | AH32.22-P-1000-02GZ | ||
| Remove/install | |||
| 1 | Open engine hood and raise to vertical position | Model 164 | AR88.40-P-1000GZ |
| Model 166 | AR88.40-P-1000GQ | ||
| 2 | Remove covers over suspension strut towers | Model 166, 292 with code 489 (AIRMATIC) | |
| Check | |||
| 3 | Check pressure line connections (1) on front suspension struts (6) | Leakage detection spray for USA |
*BR00.45-Z-1004-03A |
| Leak detection spray | *BR00.45-Z-1002-03A | ||
| Figure | |||
| Figure | |||
| If necessary, use leakage detection spray to check for leakages ↓ Repair AIRmatic pressure line connection |
AR32.22-P-2001-02GZ | ||
| Risk of death caused by vehicle slipping or toppling off of the lifting platform. | Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. | AS00.00-Z-0010-01A | |
| 4 | Lift vehicle on vehicle lift | AR00.60-P-1000GZ | |
| 5 | Check pressure line connections (2) on rear air springs (5) | Leakage detection spray for USA | *BR00.45-Z-1004-03A |
| Leak detection spray | *BR00.45-Z-1002-03A | ||
| Figure | |||
| Figure | |||
| If necessary, use leakage detection spray to check for leakages ↓ Repair AIRmatic pressure line connection |
AR32.22-P-2001-02GZ | ||
| 6.1 | Remove rear underfloor paneling | Model 164 with code 489 (AIRMATIC) | AR61.30-P-1001GZ |
| 6.2 | Remove cover of right side cover and remove load compartment floor | Model 166.0 with code 489 (AIRMATIC) | |
| 6.3 | Remove lining on the right-hand side of the trunk | Model 292 with code 489 (AIRMATIC) | AR68.30-P-4800GQC |
| 7 | Check pressure line connections (3) on central reservoirs (4) | Leakage detection spray for USA | *BR00.45-Z-1004-03A |
| Leak detection spray | *BR00.45-Z-1002-03A | ||
| Figure | |||
| Figure | |||
| If necessary, use leakage detection spray to check for leakages ↓ Repair AIRmatic pressure line connection |
AR32.22-P-2001-02GZ | ||
| 8 | Remove front section of fender liner in right front fender | Model 164 with code 489 (AIRMATIC) | AR88.10-P-1310GZ |
| Model 166, 292 with code 489 (AIRMATIC) | AR88.10-P-1310GQ | ||
| 9 | Check pressure line connection (7) to AIRmatic compressor unit (8) | Leakage detection spray for USA | *BR00.45-Z-1004-03A |
| Leak detection spray | *BR00.45-Z-1002-03A | ||
| Figure | |||
| Figure | |||
| If necessary, use leakage detection spray to check for leakages ↓ Repair AIRmatic pressure line connection |
AR32.22-P-2001-02GZ | ||
| 10 | Remove right front fog lamp | Model 164.1/8 with code 489 (AIRMATIC) | |
| Model 164.1 | AR82.10-P-5103GZ | ||
| Model 164.8 | AR82.10-P-5103GY | ||
| 11 | Check pressure line connections to AIRmatic valve unit (9) | Leakage detection spray for USA | *BR00.45-Z-1004-03A |
| Leak detection spray | *BR00.45-Z-1002-03A | ||
| Figure | |||
| Figure | |||
| If necessary, use leakage detection spray to check for leakages ↓ Repair AIRmatic pressure line connection |
AR32.22-P-2001-02GZ | ||
| 12 | Install in the reverse order |
REPAIR MATERIALS
| Number | Designation | Order number |
|---|---|---|
| BR00.45-Z-1002-03A | Leak detection spray |
Christof Fischer GmbH |
| BR00.45-Z-1004-03A | Leakage detection spray for USA | LIQUI MOLY |