LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2011 >> S550 Base >> Repair and Diagnosis >> Suspension >> Rear Suspension >> Suspension -- Testing & Repair -- S-Class (221) >> Testing & Repair >> Remove/install rear axle pressure reservoir - AR32.50-P-0011SX

Remove/install rear axle pressure reservoir - AR32.50-P-0011SX

MODEL 216, 221.0 /1 with CODE (487) Active Body Control (ABC) 

Fig 1: Identifying Rear Axle Pressure Reservoir Remove/Install Components
G07587652Courtesy of MERCEDES-BENZ USA
MODIFICATION NOTES

25.8.05 Pressure reduction time extended from 5 to 10 minutes Step 5  
  Seal pressure reservoir added Operation step 6  
REMOVINGINSTALLING Remove/install     
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. AS00.00-Z-0010-01A
NOTES Notes on fitting hydraulic lines and hoses   AH32.50-P-0001-02A
NOTES Before opening the hydraulic system, thoroughly clean the area surrounding the separation point. Even the smallest dirt particles, introduced into the hydraulic components, can lead to malfunctions and a total failure of the hydraulic system    
IMPORTANT Notes on Active Body Control suspension   AH32.50-P-0001-01N
1 Relieve pressure in the rear axle ABC system   AR32.50-P-0001-01N 
2 Remove left exhaust tailpipe Vehicles with gasoline engine AR49.10-P-7100SX
    Vehicles with diesel engine AR49.10-P-7100SXI
3 Detach cover panel (1) of spare tire well    
4 Detach heat shield (6)    
5 Remove bolt (3) and remove hydraulic line (8) from pressure reservoir (2) IMPORTANT Detach hydraulic line (8) at the earliest 10 minutes after switching off the engine, as only then is the ABC system completely unpressurized.
IMPORTANTInstallation:  Check sealing rings for damage and replace if necessary. Check support rings for damage and replace the complete hydraulic line (8) if necessary.
TORQUE SPECIFICATION
*BA32.50-P-1007-01B 
6 Seal pressure reservoir (2) with stop plugs SPECIAL TOOL Plug Fig 2
7 Unscrew nuts (4) TORQUE SPECIFICATION *BA32.50-P-1005-01B 
8 Remove rear center assembly paneling See Remove panelings in luggage compartment. AR68.30-P-4600SX
9 Remove pressure reservoir (2) If necessary:↓  
REFER TO FORMS   Dispose of pressure reservoir. OS32.30-P-0620-01A
10 Install in the reverse order    
11 Fill and bleed ABC system   AR32.50-P-0021SX 
ACTIVE BODY CONTROL SUSPENSION

Number Designation Model 216 Model 221
BA32.50-P-1005-01B Nut, rear axle pressure reservoir to spare tire well Nm 8 10
BA32.50-P-1007-01B Bolt, line to rear axle pressure reservoir Nm 20 20
Fig 2: Identifying Set Of Stop Plugs (129 589 00 91 00)
G07504337Courtesy of MERCEDES-BENZ USA