Remove/install rear rubber bushings for differential mount in rear axle carrier - AR35.10-P-0050CW
MODEL 204, 207
| Remove | |||
|---|---|---|---|
| Risk of death caused by vehicle slipping or toppling off of the lifting platform. | Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. | AS00.00-Z-0010-01A | |
| Notes on self-locking nuts and bolts | AH00.00-N-0001-01A | ||
| 1 | Shift the transmission into position "N" or into idle position | ||
| 2 | Switch off ignition | ||
| 3 | Secure vehicle on the lifting platform | AR00.60-P-0100CW | |
| 4 | Remove left and right rear diagonal strut | Model 207.4 | |
| *BA61.10-P-1007-01H | |||
| *BA61.10-P-1008-01H | |||
| *BA61.10-P-1009-01H | |||
| 5 | Detach exhaust system at connecting point of catalytic converter/center muffler and remove | Vehicles with gasoline engine | AR49.10-P-7100CW |
| Vehicles with diesel engine | AR49.10-P-7100CWI | ||
| 6 | Detach propeller shaft from differential (50) | AR41.10-P-0050CW | |
| 7 | Lash down differential (50) on rear axle carrier (4) using tensioning strap (6) | ||
| 8 | Remove struts | Model 204.9 | AR35.10-P-0042-01CWG |
| *BA35.10-P-1007-01N | |||
| *BA35.10-P-1008-01N | |||
| 9 | Open luggage compartment, remove spare tire if necessary and remove rubber plug (2) from spare wheel recess | ||
| 10 | Remove left and right bolt (3) of rear differential mount | *BA35.10-P-1006-01N | |
| 11 | Support differential (50) with transmission jack and transmission plate | ||
| 12 | Remove bolt (5) of front differential mount | *BA35.10-P-1005-01N | |
| 13 | Lower differential (50) | ||
| 14 | Press rubber bushing (10) of rear axle differential (50) out of rear axle carrier (4) | AR35.10-P-0050-02CW | |
| Fig 3 | |||
| Fig 4 | |||
| Fig 5 | |||
| Fig 6 | |||
| Fig 7 | |||
| 15 | Install in the reverse order |
REAR AXLE CARRIER
| Number | Designation | Model 204 | |
|---|---|---|---|
| BA35.10-P-1007-01N | Nut, strut to body | Nm | 25 |
| BA35.10-P-1008-01N | Bolt, strut to rear rubber mount of rear axle carrier | Nm | 25 |
REAR AXLE CARRIER
| Number | Designation | Model 204 | |
|---|---|---|---|
| BA35.10-P-1005-01N | Differential to front adapter | Nm | 65 |
| BA35.10-P-1006-01N | Bolt, rear axle differential to rear crossmember | Nm | 170 |
FRAME FLOOR ASSEMBLY
| Number | Designation | Model 207.4 | |
|---|---|---|---|
| BA61.10-P-1007-01H | Bolt, rear diagonal strut on spare wheel well | Nm | 80 |
| BA61.10-P-1008-01H | Bolt, rear diagonal strut on longitudinal member | Nm | 80 |
| BA61.10-P-1009-01H | Bolt, rear diagonal strut to bracket | Nm | 17 |