LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2010 >> C63 >> Repair and Diagnosis >> Accessories & Equipment >> Wiper/Washer Systems >> Entertainment, Lighting & Wipers/Washers - Testing & Repair - C63/C350 (204) >> Testing & Repair >> Remove/install washer fluid reservoir of windshield washer system (MODEL 204.0 /2, 207, 212, 218) - AR82.35-P-6000CW

Remove/install washer fluid reservoir of windshield washer system (MODEL 204.0 /2, 207, 212, 218) - AR82.35-P-6000CW

MODEL 204.0 /2, 207, 212, 218 

Shown on model 204.0 

Fig 1: Identifying Windshield Washer System Remove/Install Washer Fluid Reservoir
G07528426Courtesy of MERCEDES-BENZ USA

Shown on model 204.0 with gasoline engine and with code (600) Headlamp cleaning system and with code (875) Heated windshield washer system 

Fig 2: Identifying Windshield Washer System Remove/Install Washer Fluid Reservoir
G07528427Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
1 Remove expansion clips (2) and remove cover (3) Model 204, 212  
2 Remove bolt (4) and unclip bracket (5) from washer fluid reservoir (1)    
3 Unhook purge control valve (Y58/1) from bracket (7) Model 204, 207, 212 with gasoline engine  
4 Remove bolt (6)    
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. AS00.00-Z-0010-01A
5 Lift vehicle on lifting platform.
6 Remove fender liner front section    
7 Unclip washer fluid hose (8) from washer fluid reservoir (1)    
8 Unclip windshield washer system pump (M5/1) and place to one side with lines connected IMPORTANT Collect washer fluid which flows out.
IMPORTANTInstallation:  Inspect gasket, install new part if necessary.
 
SPECIAL TOOL Mounting wedge Fig 3
9 Detach hose coupling (10) For vehicles with code (600) Headlamp cleaning system  
10 Detach electrical connector (12) and expose wiring harness (13) For vehicles with code (600) Headlamp cleaning system  
11 Unclip and remove headlamp cleaning system pump (M5/2) For vehicles with code (600) Headlamp cleaning system
IMPORTANTInstallation:  Inspect gasket, install new part if necessary.
 
SPECIAL TOOL Mounting wedge Fig 3
12 Remove bolt (11)    
13 Lower washer fluid reservoir (1) IMPORTANTInstallation:  Insert pin (18) of washer fluid reservoir (1) into bracket (15).  
14 Detach electrical connector (14) from windshield washer system fluid level switch (S42)    
15 Unclip heat exchanger (17) from washer fluid reservoir (1) and guide heat exchanger (17) out of washer fluid reservoir (1) In vehicles with code (875) heated windshield washer system
IMPORTANTInstallation:  Check gasket (16) and replace if necessary. Ensure that seal (16) is seated correctly.
 
SPECIAL TOOL Mounting wedge Fig 3
16 Take off washer fluid reservoir (1)    
17 Remove windshield washer system fluid level switch (S42) When replacing the washer fluid reservoir (1).  
SPECIAL TOOL Mounting wedge Fig 3
18 Install in the reverse order    
19 Fill washer fluid reservoir (1) Model 204 AP82.35-P-8210CW
Model 207, 212, 218 AP82.35-P-8210EW
Fig 3: Identifying Mounting Wedge (110 589 03 59 00)
G07528428Courtesy of MERCEDES-BENZ USA