LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2008 >> S550 Base >> Repair and Diagnosis >> Body & Frame >> Mirrors >> Detachable Body Components -- S-Class (221) >> Testing & Repair >> Remove/install rear bumper - AR88.20-P-2200SX

Remove/install rear bumper - AR88.20-P-2200SX

MODEL 221.0/ 1 

Fig 1: Identifying Rear Bumper Components (1 Of 3)
G07586843Courtesy of MERCEDES-BENZ USA
Fig 2: Identifying Rear Bumper Components (2 Of 3)
G07586844Courtesy of MERCEDES-BENZ USA
Fig 3: Identifying Rear Bumper Components (3 Of 3)
G07586845Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
NOTES Information on preventing damage to electronic components due to electrostatic discharge AH54.00-P-0001-01A
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. AS00.00-Z-0010-01A
1 Lift vehicle on lifting platform.    
2 Remove trunk floor paneling (8)    
3 Loosen left and right side paneling in trunk (10) and connect NOTES Do not bend hinge lever passage frame (9), the plastic material can discolor.
IMPORTANT See: ↓
 
Remove paneling in trunk AR68.30-P-4600SX
4 Disconnect electrical connector from wiring harness (7)    
5 Remover mount (4) and mount (12) and lay down to side IMPORTANT Do not disconnect connectors  
6 Unscrew bolts (3) in left and right rear fender    
7 Unscrew nuts (2) inside of rear center section    
8 Unscrew bolts (13) at bottom of rear bumper (1).    
9 Loosen left and right rear fender paneling (15) with mounting wedge until bolt (14) is accessible. SPECIAL TOOL Mounting wedge Figure
10 Remove bolts (14)    
11 Remove expansion clip (16) from rear fender paneling (15) on left and right    
12 Remove rear bumper (1) IMPORTANTInstallation:  Guide hose (18) into bracket on rear bumper (1).  
13 Guide wiring harness (7) through opening in rear center section.    
14 Install in the reverse order    
15 Check gaps on rear bumper (1), adjust if necessary IMPORTANT See: ↓  
Gap dimensions on hoods, doors and lids AR60.00-P-0700-01SX
Trunk lift to bumper, dimension "L" *BE60.00-P-1003-01R
SPECIAL TOOL Feeler gauge Figure
CHECK VALUES FOR GAPS

Number Designation Model 221
BE60.00-P-1003-01R Gap dimension Trunk lid to rear fender, top Dimension "J" mm 4 (±0.5)
Trunk lid to rear lamp unit Dimension "K" mm 4 (±0.5)
Trunk lid to bumper Dimension "L" mm 5.5 (±1.5)
Rear fender to rear lamp unit Dimension "M" mm 2.5 (±0.5)
Trunk lid license plate panel to rear lamp unit Dimension "N" mm 4 (±0.5)
See picture AR60.00-P-0700-01SX
Fig 4: Identifying Mounting Wedge (110 589 03 59 00)
G07586846Courtesy of MERCEDES-BENZ USA
Fig 5: Identifying Feeler Gauge (129 589 03 21 00)
G07586847Courtesy of MERCEDES-BENZ USA