LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2007 >> SLK280 Standard >> Repair and Diagnosis >> Brakes >> Mechanical - Hydraulic >> Brakes - 171 Chassis >> Testing & Repair >> Remove/install rear axle brake caliper - AR42.10-P-0080V

Remove/install rear axle brake caliper - AR42.10-P-0080V

MODEL 171.442 /454 /456 

Fig 1: Identifying Rear Axle Brake Caliper Components
G05027610Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install    
DANGER Risk of death  caused by vehicle slipping or toppling off of the lifting platform. Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer. -
DANGER Risk of poisoning  caused by swallowing brake fluid. Risk of injury  caused by brake fluid coming into contact with skin and eyes. Only pour brake fluid into suitable and appropriately marked containers. Wear protective clothing and eye protection when handling brake fluid. -
NOTES Brake fluid notes   AH42.50-P-0001-01A 
NOTES Notes on repairs to brake system   AH42.00-P-0003-01A 
1 Hoist vehicle with lifting platform until wheels are free   AR00.60-P-1000V
2 Remove rear wheels.    
REFER TO MAINTENANCE Remove/install wheels, rotate if necessary   AP40.10-P-4050V
3 Remove brake pads on rear axle   AR42.10-P-1700V 
4.1 Unscrew bolt (1) and remove right rear brake pad contact sensor connector (X88/15) from brake caliper (31) Model 171.456  
    TORQUE SPECIFICATION *BA42.10-P-1003-12P 
5 Remove brake hose (51) IMPORTANTSPECIAL TOOL Seal off line connections immediately with plugs. The brake fluid expansion reservoir must not run empty. AR42.10-P-0013V 
    SPECIAL TOOL Set of stop plugs Figure
6 Unscrew bolts (31s) and remove brake caliper (31) TORQUE SPECIFICATION *BA42.10-P-1001-12P 
7 Install in the reverse order    
8 Bleed brake system   AR42.10-P-0010V 
DANGER Risk of accident  when commissioning the vehicle due to a lack of braking effect when the service brake is operated for the first time after repair work Before starting engine, actuate brake pedal several times until the pressure is built up and maintained in the brake system. -
9 Operate the brake pedal several times until brake pads make contact with the brake disks (61) IMPORTANT The brake pads have made contact with the brake disks (61) when a firm resistance can be felt at the brake pedal.  
10 Check brake system for leaks   -
INSPECT Checking     
11 Inspect fluid level in expansion reservoir, adjust to correct level if necessary FLUID SPECIFICATION *BF42.10-P-1001-01A 
REFER TO MAINTENANCE Brake system - inspect fluid level   AP42.10-P-4210V 
DANGER Risk of death  caused by body parts being pulled in by rotating vehicle wheels and roller dynamometer rollers Do not insert your hand into rotating parts.
Wear closed and snug-fitting work clothes.
Safeguard areas with rotating vehicle parts and dynamometer rollers against unauthorized access.
Safeguard roller dynamometer from unauthorized access.
-
12 Carry out brake test on the test stand    
REFER TO MAINTENANCE Brake testing on test stand   AP42.00-P-4290V 
REAR AXLE BRAKE CALIPER

Number Designation Model 171 except 171.473 Model 171.473
BA42.10-P-1001-12P Self-locking bolt, brake caliper to wheel carrier Nm 55 85
BA42.10-P-1003-12P Bolt, brake pad contact sensor to brake caliper Nm 7 7
BRAKE FLUID

Number Designation Model 171
BF42.10-P-1001-01A Brake fluid Filling capacity Liters ≈ 0.45 to 0.6
Specifications for Operating Fluids Sheet BB00.40-P-0330-01A
  Sheet BB00.40-P-0331-00A
Fig 2: Identifying Set Of Stop Plugs (129 589 00 91 00)
G05027611Courtesy of MERCEDES-BENZ USA