LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2007 >> SLK280 Automatic >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Climate Control - 171 Chassis >> Testing & Repair >> Remove/ install/ replace duovalve - AR83.25-P-1150V

Remove/ install/ replace duovalve - AR83.25-P-1150V

MODEL 171.4 

Shown on model 171.4 with engine 271 

Fig 1: Identifying Duovalve Components - Shown On Model 171.4 With Engine 271
G05033991Courtesy of MERCEDES-BENZ USA
MODIFICATION NOTES

5.7.06 "Disconnect/connect battery ground line" removed
REMOVINGINSTALLING Remove/install    
DANGER Risk of injury  to skin and eyes caused by scalding from contact with hot coolant spray. Risk of poisoning  caused by swallowing coolant. Do not open cooling system unless coolant temperature is below 90°C. Open cap slowly and release the pressure. Do not pour coolant into beverage containers.
Wear protective gloves, protective clothing and safety glasses.
-
1 Open engine hood and raise to vertical position   AR88.40-P-1000V
2 Reduce pressure in cooling system IMPORTANT To do this, carefully open reservoir cover and close again.  
3.1 Remove right air filter housing Model 171.454/456 AR09.10-P-1150VA
4 Unscrew nuts (1).    
5 Push heat shield (2) to one side until the hot water hoses (3) and the hot water hose (5) are accessible    
6 Loosen windshield washer fluid hose (4) from the heating water hose mount (5) and put to one side    
7 Loosen heating water hose (5) from bracket (6) IMPORTANTInstallation:  Ensure proper seating of heating water hose (5) in bracket (6).  
8 Clamp off heating water hoses (3) SPECIAL TOOL Fig 3
9 Clamp off heating water hose (5) SPECIAL TOOL Fig 2
10 Loosen clamp (7) IMPORTANTInstallation:  Clamp (7) must audibly engage.  
11 Remove duovalve (Y21) with connected heating water hose (5) upward IMPORTANT Catch leaking coolant.  
12 Disconnect electrical connector (8)    
13 Release clamp (9)    
14 Detach heating water hose (5) from duovalve (Y21) IMPORTANT Catch leaking coolant.  
15 Install in the reverse order    
16 Check coolant level, correct if necessary    
REFER TO CAPACITIES & SPECIFICATIONS Coolant specifications Sheet 310.1 BB00.40-P-0310-01A
REFER TO CAPACITIES & SPECIFICATIONS Anticorrosion/antifreeze agents (Sheet 325.0) Sheet 325.0 BB00.40-P-0325-00A
17 Bleed cooling system   AR20.00-P-1142
18 Inspect cooling system for leaks Model 171.442/454/456 AR20.00-P-1010V
    Model 171.473 AR20.00-P-1010P
Fig 2: Identifying Clamping Device (000 589 40 37 00)
G05033992Courtesy of MERCEDES-BENZ USA
Fig 3: Identifying Clamping Device (000 589 54 37 00)
G05033993Courtesy of MERCEDES-BENZ USA