LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2007 >> CLS550 >> Repair and Diagnosis >> Brakes >> Mechanical - Hydraulic >> Brakes - Hydraulic & Mechanical Systems - 219 Chassis >> Testing & Repair >> Remove/install rear brake control cable - AR42.20-P-0525TX

Remove/install rear brake control cable - AR42.20-P-0525TX

MODEL 219 

Fig 1: Identifying Rear Brake Control Cable Remove/Install Components (1 Of 2)
G10767984Courtesy of MERCEDES-BENZ USA
Fig 2: Identifying Rear Brake Control Cable Remove/Install Components (2 Of 2)
G10767985Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
1 Remove parking brake shoes   AR42.20-P-0530TX 
2 Remove crossmember (35) TORQUE SPECIFICATION *BA62.30-P-1001-01C 
3 Support exhaust system using COMMERCIALLY AVAILABLE TOOLS transmission platform and COMMERCIALLY AVAILABLE TOOLS transmission jack, detach it from rubber retainers and lower COMMERCIALLY AVAILABLE TOOLS *WE58.40-Z-1018-11A 
COMMERCIALLY AVAILABLE TOOLS *WE58.40-Z-1030-11A 
4 Loosen, separate and move heat shields or remove them Depending on accessibility  
Model 219 except 219.322 AR49.00-P-1000-01TX
Model 219.322 AR49.10-P-6906TQ
5 Detach retracting spring (94) from bridge (70) INSTALLATION IMPORTANT After installing retracting spring (94): ↓  
Relieve load on automatic slack adjuster. AR42.20-P-0520-02TX
6 Detach front brake cable (85) from automatic cable slack adjuster (92)    
7 Preload automatic slack adjuster (92)   AR42.20-P-0520-01TX
8 Detach rear brake cable (86) at automatic cable slack adjuster (92)    
9 Unclip rear brake cable (86) from bridge (70) SPECIAL TOOL Figure
10 Pull rear brake cable (86) out of center assembly mount (51) NOTES While working on the rear axle care must be taken to ensure that the surface of all aluminum components do not get any scratches, cracks and notches. Otherwise the service life of the of the parts will be reduced.
IMPORTANT Lever rubber grommet (86a) out of center assembly mount (51).
 
11 Pull rear brake cable (86) out of wheel carrier    
12 Press together retaining collar (86b) and pull down and out of bracket (86c) together with rear brake cable (86).    
13 Install in the reverse order    
CROSSMEMBER AND FRONT REINFORCEMENT

Number Designation Model 219
BA62.30-P-1001-01C Bolt, crossmember to body Nm 25
Fig 3: Identifying Snap-Release Tool (129 589 11 63 00)
G10767986Courtesy of MERCEDES-BENZ USA
WORKSHOP EQUIPMENT

WE58.40-Z-1018-11A Transmission platform
WE58.40-Z-1030-11A Transmission jack