LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2007 >> CLK63 >> Repair and Diagnosis >> Accessories & Equipment >> Wiper/Washer Systems >> Exterior Lights, Wiper/Washer, Entertainment, & Antenna -- Testing & Repair - 209 Chassis >> Testing & Repair >> Remove/install xenon bulb ignition module - AR82.10-P-4633QA

Remove/install xenon bulb ignition module - AR82.10-P-4633QA

MODEL 209 as of 17.5.05 with CODE (614) Bi-xenon headlamp unit 

MODEL 209 as of 17.5.05 except CODE (615) Bi-xenon headlamp unit with integrated curve illumination 

Fig 1: Identifying Xenon Bulb Ignition Module Components
G04959909Courtesy of MERCEDES-BENZ OF NORTH AMERICA.

Shown with code 615 Bi-xenon headlamp unit with integrated curve illumination 

REMOVINGINSTALLING Remove/install    
DANGER Risk of death  caused by high voltage levels present at xenon headlamps.
Risk of explosion/fire hazard  due to highly flammable substances in the area of damaged xenon bulbs
Risk of injury  due to UV light, hot components on xenon headlamps and glass splinters when xenon bulbs burst
Risk of poisoning  caused by inhalation of mercury vapors and by toxic salts and mercury compounds being ingested or coming into contact with skin
Do not come into contact with parts that are under high voltage. Persons with active electronic implants  (e.g. heart pacemakers) must never work on xenon headlamps. Switch off entire lighting system. Wear insulated safety shoes, safety glasses and protective gloves. Remove highly inflammable materials from the hazard area. Ensure sufficient ventilation in the working area. AS82.10-Z-0001-01A
1 Switch off the ignition and remove the transmitter key from the EIS control unit    
2 Open engine hood and secure against falling down   AR88.40-P-1000Q
3 Remove air pump Vehicles with code P98 Black Series for removal of left xenon headlamp ignition module (E1n2)  
4 Turn housing cover (low beam) (1) from left/ right front lamp unit (E1/E2) to left and remove IMPORTANTInstallation:  Ensure that housing cover (low beam) (1) is properly seated.  
5 Disconnect electrical connector (3) from xenon headlamp ignition module (E1n2/E2n2)    
6 Turn xenon headlamp ignition module (E1n2/ E2n2) to the left and carefully pull out with left/right low beam (E1e2/E2e2) IMPORTANT The xenon headlamp ignition module (E1n2) with left low beam (E1e2) and xenon headlamp ignition module (E2n2) with right low beam (E2e2) are a component each and can only be replaced as a pair.
NOTESInstallation:  Do not touch the glass bulbs with bare hands. Use a soft cloth free of grease and pay attention to correct installation position. Otherwise, the deposits that develop can reduce the light output of the reflector.
 
7 Install in the reverse order    
8 Perform a function test