LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2005 >> CL500 >> Repair and Diagnosis >> Steering >> Power Steering >> Steering -- Testing & Repair -- 215 & 220 Chassis >> Testing & Repair >> Remove/install hydraulic line of power steering - AR46.25-P-3015 >> Remove/install hydraulic line of power steering - AR46.25-P-3015MC

Remove/install hydraulic line of power steering - AR46.25-P-3015MC

MODELS 220.176 

Hydraulic line (return line) from rack-and-pinion steering to oil cooler 

Fig 1: Identifying Return Flow Pipe, Heat Shield, Bracket, Bolts And Screw
G04853049
REMOVINGINSTALLING Remove/Install     
DANGER Risk of death  cased by vehicle slipping or toppling off of the lifting platform. Align vehicle between the columns of the lifting platform and position the four support plates at the lifting platform support points specified by the vehicle manufacturer. AS00.00-Z-0010-01A
NOTES Before opening the hydraulic system the area surrounding the separation point should be cleaned thoroughly. Even the smallest dirt particles, introduced into the hydraulic components, can lead to malfunctions and a total failure of the hydraulic system    
1 Open engine hood   AR88.40-P-1000M
2 Remove left engine intake air duct upstream of the air cleaner housing    
3 Remove left side of air cleaner housing   AR09.10-P-1150LA
4 Remove expansion reservoir for power steering pump and Active Body Control   AR46.25-P-1000MB 
5 Detach return line (1) from power steering cooler IMPORTANTSPECIAL TOOL Seal connections with plugs.  
    SPECIAL TOOL Set of plugs Figure
6 Raise vehicle with lifting platform    
7 Remove engine compartment paneling IMPORTANTInstallation:  Only after function test and leak test is complete. AR61.20-P-1105M
8 Detach return line (1) from front axle carrier; to do this, unscrew bolt (2) and remove bracket (3) through the recess TORQUE SPECIFICATION *BA46.30-P-1025-01C 
9 Unscrew bolts (4) from front axle carrier and heat shield (5) IMPORTANT Unscrew the bolts (4) from above.  
10 Remove rack-and-pinion steering   AR46.20-P-0600M 
11 Take out return line (1) downwards    
12 Install in the reverse order    
13 Fill power steering pump and bleed   AR46.30-P-0010N 
14 Check power steering for proper operation and hydraulic line connections for leaks    
TORQUE SPECIFICATION POWER STEERING PUMP

Number Designation Models 215.376/379, 220.176/179 with code 487a
BA46.30-P-1025-01C Bolt, bracket of return line to front axle carrier Nm 6
Fig 2: Set Of Plugs (129 589 00 91 00)
G04853050