LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2004 >> S430 Base >> Repair and Diagnosis >> Accessories & Equipment >> Interior/Illumination Lights >> Entertainment, Lighting & Navigation -- Retrofitting & Conversion -- 215 & 220 Chassis >> Retrofitting & Conversion >> Retrofit navigation system - AN82.85-P-0002M

Retrofit navigation system - AN82.85-P-0002M

MODELS 220.025 /028 /063 /067 /070 /075 /083 /084 /087 /125 /128 /167 /170 /175 /176 /183 /184 /187 1# as of 1.9.03 

Fig 1: Identifying Navigation System Components Location
G04852758
DISASSEMBLING Remove     
DANGER Risk of explosion  caused by explosive gas. Risk of poisoning and caustic burns  caused by swallowing battery electrolyte. Risk of injury  caused by burns to skin and eyes from battery acid or when handling damaged lead-acid batteries No fire, sparks, open flames or smoking.
Wear protective gloves, acid-resistant clothing and safety glasses. Pour battery electrolyte only into suitable and appropriately marked containers.
AS54.10-Z-0001-01A
1 Disconnect battery ground line IMPORTANT Do not connect quiescent current retention device.  
REFER TO TESTING & REPAIR     AR54.10-P-0003I
NOTES Notes on battery All models AH54.10-P-0001-01A
IMPORTANT Notes on AGM battery Model 220.028 with CODE (450) Taxi version.
Models 220.070/075/175 as of 1.1.01
AH54.10-P-0002-01A
2.1 Remove operating lever for mechanically pivotable trailer hitch IMPORTANT Vehicles with code (550) trailer hitch.  
REFER TO TESTING & REPAIR     AR31.11-P-8010M
3 Remove coverings in trunk IMPORTANT Left side paneling.
IMPORTANT If a side wall paneling without access flap for the navigation processor has been installed, this must be replaced with a new one having an access flap.
 
REFER TO TESTING & REPAIR     AR68.30-P-4600M
4 Remove audio gateway control unit IMPORTANT Do not disconnect electrical lines and do not remove control units from the brackets.  
REFER TO TESTING & REPAIR     AR82.60-P-7606M
DISASSEMBLING Install     
5 Extend fiber optical cable ring for components to be retrofitted NOTESRisk of breakage!  Do not kink optical waveguide, route over sharp edges or bend in radii smaller than 25 mm. Tensile forces on inserts must not exceed 65 N. Do not squeeze fiber optical cable and do not compress with clamps or tie straps. AN82.64-P-0001-05MA 
6 Install audio gateway control unit    
REFER TO TESTING & REPAIR     AR82.60-P-7606M
7 Retrofitting navigation processor in trunk   AN82.85-P-0001-01MA 
8 Fit remaining parts to vehicle IMPORTANT Steps 3 up to 1  
9 Perform startup with STAR DIAGNOSIS. IMPORTANT Perform specified/actual configuration and enable navigation special equipment in the instrument cluster.  
10 Perform function check IMPORTANT See owner's manual.  
11 Add special equipment to the vehicle data card and to the online vehicle data card IMPORTANT COMAND APS USA (with navigation) code 527a  
PARTS ORDERING NOTES

Part no. Designation Quantity
A211 540 31 32 MOST wiring harness 1
KG82Group 82 (see EPC) Navigation processor 1
KG82Group 82 (see EPC) Navigation DVD 1
KG82Group 82 (see EPC) Navigation processor/CD changer bracket (not for Code 819) 1
KG82Group 82 (see EPC) Screw for attaching navigation processor/CD changer bracket (not for Code 819) 1
KG82Group 82 (see EPC) Nut for attaching navigation processor/CD changer bracket (not for Code 819) 1
KG68Group 68 (see EPC) If applicable, left luggage compartment side paneling (not for Codes 433/434/810/819/860/862) 1