LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2002 >> ML320 >> Repair and Diagnosis >> Brakes >> Mechanical - Hydraulic >> Brakes -- 163 Chassis >> Self-Diagnostic System >> Electronic stability program (ESP) and BAS diagnosis, fault memory (Fault Codes C1000, C1010, C1012, C1020, C1022, C1024, C1025, C1030, C1032, C1100, C1101, C1102, C1103, C1120, C1140, C1141, C1142, C1200, C1201, C1202, C1203, C1204, C1205, C1206, C1207, C1210, C1300, C1301, C1302, C1303, C1304, C1305, C1306, C1307, C1314, C1316, C1317, C1318, C1319, C1332, C1401, C1511, C1512, C1528, C1529) - AD42.45-P-4002A

Electronic stability program (ESP) and BAS diagnosis, fault memory (Fault Codes C1000, C1010, C1012, C1020, C1022, C1024, C1025, C1030, C1032, C1100, C1101, C1102, C1103, C1120, C1140, C1141, C1142, C1200, C1201, C1202, C1203, C1204, C1205, C1206, C1207, C1210, C1300, C1301, C1302, C1303, C1304, C1305, C1306, C1307, C1314, C1316, C1317, C1318, C1319, C1332, C1401, C1511, C1512, C1528, C1529) - AD42.45-P-4002A

MODEL 163 with CODE (472a) Electronic Stability Program (ESP) 

DANGER Risk of fatal accident  if the vehicle slips off the lifting platform Align vehicle between the columns of the lifting platform and position the four support plates at the lifting platform support points specified by the vehicle manufacturer. AS00.00-Z-0010-01A
  Electronic stability program (ESP) and BAS diagnosis, background knowledge   AD42.45-P-2002A 
  Connect hand-held tester (HHT) and read out fault memory Model 163 up to 31.8.01 AD00.00-P-2000-03C  
IMPORTANT The BAS control module is integrated into the ESP control module (N47-5)     
IMPORTANT Read out fault memory of ESP, ME-SFI and ETC systems    
NOTES After replacing  the components: lateral acceleration sensor  and/or yaw rate sensor  , the following road test must be performed to check the function of these components. Model 163 as of 01.00
Function check of ESP lateral acceleration sensor
Model 163 as of 01.00
Function check of ESP yaw rate sensor
AD42.45-P-3000-02A 
AD42.45-P-3000-03A 
NOTES Reconfiguration of the control module (N47-5) is essential after replacing the ESP control module (N47-5)  or the brake booster (A7/7)  The values for the BAS solenoid valve must be read into the ESP control module (N47-5). See HHT menu.  
NOTES Reconfiguration of the ESP control module (N47-5)  is essential after replacing the control module (N47-5). Code steering ratio.
See HHT menu.
 
  Fault memory     
Fault code HAND-HELD TESTER Possible cause  Notes  Remedy 
No fault code   In the event of a complaint, perform a full test of the ESP and BAS electrical system AD42.45-P-6002A 
C1000 ESP/BAS ESP/BAS control module (N47-5) IMPORTANT Reconfigure control modules after replacing parts N47-5
C1010 ESP/BAS Voltage supply
Undervoltage
  AD42.45-P-6000-01C 
C1012 ESP/BAS Voltage supply
Overvoltage
  AD42.45-P-6000-01C 
C1020 ESP CAN communication  General fault   Check coding
AD42.45-P-6000-35B 
C1022 ESP/BAS CAN communication  with engine control module (ME-SFI) (N3/10) faulty   Check coding Read out ME-SFI fault memory (Engine) AD42.45-P-6000-35B 
C1024 ESP CAN communication  with ETC control module (N15/3)   Read out ETC fault memory (Chassis)
C1025 BAS CAN communication  with BAS IMPORTANT Reconfigure control modules after replacing parts N47-5
C1030 ESP CAN communication  with transfer case control module (N78) faulty   Read out transfer case fault memory (Chassis)
C1032 ESP CAN communication  with instrument cluster (A1) faulty   Read out instrument cluster (A1) fault memory
C1100 ESP Left front wheel speed sensor (L6/1) 
Open circuit, loose contact, plausibility
Rotor with wrong number of teeth, dirty or damaged,
incorrect final drive ratio, tires or wheels.
AD42.45-P-6000-08A 
C1101 ESP Right front wheel speed sensor (L6/2) 
Open circuit, loose contact, plausibility
Rotor with wrong number of teeth, dirty or damaged,
incorrect final drive ratio, tires or wheels.
AD42.45-P-6000-10A 
C1102 ESP Left rear wheel speed sensor (L6/3) 
Open circuit, loose contact, plausibility
Rotor with wrong number of teeth, dirty or damaged,
incorrect final drive ratio, tires or wheels.
AD42.45-P-6000-12A 
C1103 ESP Right rear wheel speed sensor (L6/4) 
Open circuit, loose contact, plausibility
Rotor with wrong number of teeth, dirty or damaged,
incorrect final drive ratio, tires or wheels.
AD42.45-P-6000-14A 
C1120 ESP ESP yaw rate sensor (B45) 
Signal line: open circuit / short circuit
Reference wire: open circuit / short circuit
  AD42.45-P-6000-32B 
C1140 ESP Steering angle sensor (N49) 
Initialization,
Open circuit / short circuit
  To initialize, turn steering wheel from lock to lock. AD42.45-P-6000-06B 
C1141 ESP ESP pressure sensor 1 (B34/1)  or ESP pressure sensor 2 (B34/2) 
Open circuit / short circuit, plausibility
  AD42.45-P-6000-31B 
C1142 ESP Lateral acceleration sensor (B43) 
Open circuit / short circuit, voltage supply, plausibility
  AD42.45-P-6000-30B 
C1200 ESP Stop lamp switch (S9/1) 
Plausibility
  AD42.45-P-6000-36A 
C1201 BAS BAS release switch (A7/7s1) 
Open circuit / short circuit
IMPORTANT Reconfigure control modules after replacing parts Read out HHT actual value, cables, A7/7s1
C1202 BAS BAS release switch (A7/7s1) 
Plausibility
IMPORTANT Reconfigure control modules after replacing parts Read out HHT actual value, cables, A7/7s1
C1203 BAS BAS release switch (A7/7s1) 
Redundancy
IMPORTANT Reconfigure control modules after replacing parts Read out HHT actual value, Cable, A7/7s1
C1204 BR5 BAS diaphragm travel sensor (A7/7b1) 
Open circuit / short circuit
  Read out HHT actual value, AD42.45-P-6000-33B 
C1205 BR5 BAS diaphragm travel sensor (A7/7b1) 
Plausibility
  Read out HHT actual value, AD42.45-P-6000-33B 
C1206 BR5 BAS diaphragm travel sensor (A7/7b1) 
Diaphragm speed
  Read out HHT actual value, AD42.45-P-6000-33B 
C1207 BAS Stop lamp switch (S9/1) 
Plausibility
  AD42.45-P-6000-36A 
C1210 ESP Brake fluid level switch (S11) 
Open circuit / short circuit
  Read out HHT actual value,
C1300 ESP Left front pressure hold solenoid valve (A7/3y6) 
Open circuit / short circuit
  AD42.45-P-6000-18A 
C1301 ESP Left front pressure reduction solenoid valve (A7/3y7) 
Open circuit / short circuit
  AD42.45-P-6000-19A 
C1302 ESP Right front pressure hold solenoid valve (A7/3y8) 
Open circuit / short circuit
  AD42.45-P-6000-20A 
C1303 ESP Right front pressure reduction solenoid valve (A7/3y9) 
Open circuit / short circuit
  AD42.45-P-6000-21A 
C1304 ESP Left rear pressure hold solenoid valve (A7/3y10) 
Open circuit / short circuit
  AD42.45-P-6000-22A 
C1305 ESP Left rear pressure reduction solenoid valve (A7/3y11) 
Open circuit / short circuit
  AD42.45-P-6000-23A 
C1306 ESP Right rear pressure hold solenoid valve (A7/3y12) 
Open circuit / short circuit
  AD42.45-P-6000-24B 
C1307 ESP Right rear pressure reduction solenoid valve (A7/3y13) 
Open circuit / short circuit
  AD42.45-P-6000-25B 
C1314 ESP Solenoid valves 
Voltage supply, open circuit or short circuit in cable
  AD42.45-P-6000-01C 
AD42.45-P-6000-17B 
C1316 ESP Pressure circuit 1 switchover solenoid valve (A7/3y24) 
Open circuit / short circuit
  AD42.00-P-6000-28A 
C1317 ESP Pressure circuit 1 intake solenoid valve (A7/3y26) 
Open circuit / short circuit
  AD42.00-P-6000-30A 
C1318 ESP Pressure circuit 2 switchover solenoid valve (A7/3y25) 
Open circuit / short circuit
  AD42.00-P-6000-29A 
C1319 ESP Pressure circuit 2 intake solenoid valve (A7/3y27) 
Open circuit / short circuit
  AD42.00-P-6000-31A 
C1332 BAS BAS solenoid valve (A7/7y1)  , open circuit / short circuit IMPORTANT Reconfigure control modules after replacing parts AD42.45-P-6000-34B 
C1401 ESP High-pressure/return pump (A7/3m1) 
Open circuit / short circuit
Fails to switch off or stops too quickly
  AD42.45-P-6000-04B 
C1511 BAS BAS coding faulty   Perform HHT coding
C1512 ESP Brakes overheating   Brake was overloaded temporarily, erase fault
C1528 ESP ESP stop lamp suppression relay (F1k6) IMPORTANT Reconfigure control modules after replacing parts AD42.45-P-6000-07B 
C1529 ESP Preloading by BAS solenoid valve (A7/7y1) not available IMPORTANT Reconfigure control modules after replacing parts Read out BAS fault memory
AD42.45-P-6000-34B