Risk of death caused by limbs being caught or squeezed by rotating parts when performing tests on the brake test stand - AS42.00-Z-0001-01A

Never leave the vehicle unattended on the rollers except in an emergency. 

Ensure that no one is under the vehicle or near rotating parts during testing. In case of emergency, use the 

EMERGENCY STOP switch to shut down test stand. 

Risk of death 

Life-threatening  injuries may be caused by contact with rotating engine or drive train parts or by coming to close to the brake test stand rollers.

Safety precautions/instructions 

• The brake test stand is to be operated by trained personnel  only.
• Before driving the vehicle onto the rollers, the driver must ensure that the test stand is ready for operation (main switch is on)  .
• For as long as the vehicle in on the rollers, no one  is permitted under the vehicle or in the pit.
• For as long as the vehicle in on the brake test stand, the driver may only leave the driver's seat in the event of an emergency.
• During the test, no one is allowed to go near the rotating rollers, wheels, or propeller shafts.
• In case of emergency, shut off brake test stand using the red EMERGENCY STOP switch  .

When testing the ABS and where sections 29 and/or 57b of the StVZO (German vehicle licensing regulations) apply, please also observe the following: 

• The test stand must be switched from "Automatic" to "Manual" before driving the vehicle onto the rollers.
• The remote control for testing the ABS may only be operated from the driver's seat.