LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2000 >> ML430 >> Repair and Diagnosis (Single Page) >> Accessories & Equipment >> Collision/Avoidance >> Electrical System, Equipment & Instructions -- 163 Chassis >> Basic Knowledge >> Fuse and relay box, fuses, relay holder - GF54.15-P-1255-15GH

Fuse and relay box, fuses, relay holder - GF54.15-P-1255-15GH

Fig 1: Identifying Fuse Relay Box And Relay Holder
G04607660
Fuse Circuit Color of unfused wire Fused function Rating in amperes (A)
F1 15 5.0 mm 2 red Interior socket (X58/1) 15
F2 L 0.5 mm 2 green
1.0 mm 2 green		 Instrument cluster (A1):
  • Left turn signal indicator lamp (A1e1)

Left front lamp unit (E1):
  • Left turn signal lamp (E1e5)

Left taillamp (E3):
  • Left turn signal lamp (E3e1)

Left additional turn signal lamp (E22/1)
Interior connector sleeve (circuit L) (Z53/4):
  • Trailer hitch connector (X52)
 7.5
F3 56a 2.0 mm 2 beige 1.0 mm 2 white Right front lamp unit (E2):
  • Right high beam (E2e1)
 15
F4 30 2.0 mm 2 white Tilting/sliding roof (SR [SHD]) supply (M12), circuit 30:
  • Tilting/sliding roof (SR [SHD]) (M12)
 30
F5 56a 1.0 mm 2 white
0.5 mm 2 white		 Left front lamp unit (E1):
  • Left high beam (E1e1)

Instrument cluster (A1):
  • High beam indicator lamp (A1e3)
 7.5
F6 15 0.8 mm 2 green Rear-end door wiper motor (M6/4) 7.5
F7 30
53a		 2.0 mm 2 white
1.0 mm 2 white		 Combination switch (S4):
  • Hazard warning flasher switch (S4s10)
  • Windshield washer system switch (S4s4)
  • Wipe switch (S4s5)

Wiper motor (M6/1)
Front wiper motor relay (F1 k17)		 15
F8 30 1.0 mm 2 red Transfer case control unit (N78) 25
F9 58 0.5 mm 2 gray
0.8 mm 2 gray		 Instrument cluster (A1)
License plate illumination:
  • Left rear-end door license plate lamp (E19/3)/ right rear-end door license plate lamp (E19/4)
  • Left spare wheel carrier license plate lamp (E19/5)/right spare wheel carrier license plate lamp (E19/6)

Cockpit connector sleeve (circuit 58d) (Z50/1):
  • Left vent window switch (S21/13)/right vent window switch (S21/14) (light emitting diodes)
  • Left front HS [SIH] switch (S51/1)/right front HS [SIH] switch (S51/2) (light emitting diodes)
  • Heater/AC switch (S98) (light emitting diodes)
  • Double switch combination (S97/6) (light emitting diodes)
  • ESP OFF switch (S76/6) (light emitting diodes)
  • Outside mirror fold-in/fold-out switch (S50/1) (light emitting diode)
  • Electric headlamp range adjustment selector wheel (S1/1) (light emitting diode)
  • Rear window wipe/wash switch (S78) (light emitting diode)
  • Tilting/sliding roof switch (S13/2) (light emitting diode)
  • Backup lamp switch (S16/2)
  • Illumination (R3e1)
  • Center console switch group (S21)
 7.5
F10 15R 0.5 mm 2 pink Radio (A2)
Circuit 15R roof connector sleeve (Z54/1):
  • Left sun visor with illuminated mirror (E14/1)
  • Right sun visor with illuminated mirror (E14/2)
  • Trip computer (TRIP [RRE]) control unit (N41)
  • Automatic dimming inside rearview mirror (H7)

Front cigar lighter (with ashtray illumination) (R3):
  • Heating element (R3r1)

Glove compartment lamp (E13/1)
Instrument cluster (A1):
  • Airbag indicator and warning lamp (A1e15)
 10
F11 15 1.5 mm 2 red/blue Hot film MAF sensor (B2/5)
Crankshaft position sensor (L5)
Fuel injection valves (Y62)
On M111:
  • HFM-SFI [HFM] control unit (N3/4)
 10
F12 58L 0.8 mm 2 blue
1.0 mm 2 blue		 Circuit 58L interior connector sleeve (Z53/6):
  • Trailer hitch connector (X52)

Left taillamp (E3):
  • Left taillamp and parking lamp (E3e2)

Left front lamp unit (E1):
  • Left standing and parking lamp (E1e3)
  • Leftside-marker lamp (E1e6)
 7.5
Fuse Circuit Color of unfused wire Fused function Rating in amperes (A)
F13 30 2.0 mm 2 red
0.5 mm 2 red
0.5 mm 2 red
0.5 mm 2 red		 Circuit 30 roof connector sleeve (Z54/2):
  • Front dome lamp with shut-off delay and front reading lamp (E15/2)
  • Rear interior lamp (E15/3)
  • Left rear dome lamp (E15/8)
  • Right rear dome lamp (E15/9)
  • Trip computer (TRIP [RRE]) control unit (N41) Instrument cluster (A1):
  • Seat belt warning lamp (A1E9)

Steering angle sensor (N49)
Data link connector (X11/4)		 10
F14 15   On diesel:
Injection timing device
Exhaust gas recirculation valve		 10
F15 54 1.0 mm 2 orange Interior connector sleeve (circuit 54) (Z52/6)
Left taillamp (E3):
  • Left stop lamp (E3e4)

Right taillamp (E4):
  • Right stop lamp (E4e4)
  • Center high-mounted stop lamp (E21)
  • Center high-mounted stop lamp on spare wheel mount (E35)
  • Trailer hitch connector (X52)
 10
F16 15 0.5 mm 2 gray
1.0 mm 2 gray		 Data link connector (X11/4)
Backup lamp switch (S16/2)
Cockpit connector sleeve (circuit 15) (Z50/2):
  • AC control unit (N19)
  • Heater/AC switch (S98)
    • Blower switch (S98s1)
    • Temperature control switch (S98p1)
    • Air recirculation switch indicator lamp (S98e3)
    • Illumination (S98e1)
    • Illumination (S98e2)
    • Air recirculation switch (S98s2)
    • AC ON indicator lamp (S98e4)
    • AC ON switch (S98s3)
  • Air recirculation flap actuator motor (M39)
  • AC control unit (N19)
 15
F17 30 2.0 mm 2 red Load compartment socket (X58/4) 15
F18 30 2.0 mm 2 red Trailer hitch connector (X52) 25
F19 30 2.5 mm 2 red/green
0.5 mm 2 blue
1.0 mm 2 blue
1.0 mm 2 blue		 M111:
HFM-SFI [HFM] control unit (N3/4)
Adjustable camshaft timing solenoid (Y49)
USA version:
Activated charcoal filter shutoff valve (Y58)
M112/113:
Circuit 87 M2e connector sleeve (Z7/36):
  • Variable intake manifold switchover valve (Y22/6)
  • EGR [ARF] switchover valve (Y27)
  • Air pump switchover valve (Y32)
  • Left O2 sensor upstream of TWC [KAT] (G3/3)
  • Right O2 sensor upstream of TWC [KAT] (G3/4)

Purge control valve (Y58/1)
Left O2 sensor downstream of TWC [KAT] (G3/5)
Right O2 sensor downstream of TWC [KAT] (G3/6)		 15
F20 15 0.5 mm 2 pink Left electrically adjustable and heated outside mirror (M21/1), right electrically adjustable and heated outside mirror (M21/2) 15
F21 30 1.0 mm 2 red Sound system:
Sound amplifier (A2/13)
Radio (A2)		 25
Fuse Circuit Color of unfused wire Color of unfused wire Fused function Rating in amperes (A)
F22 15   2.0 mm 2 blue
0.5 mm 2 blue
0.5 mm 2 blue
1.0 mm 2 blue
0.5 mm blue		 Circuit 15 interior connector sleeve (Z51/5):
  • ETC [EGS] control unit (N15/3)
  • Gear recognition switch (S16/10)
  • Reversing and parking lock locking solenoid (Y66/1)
  • Transfer case control unit (N78)
  • Traction systems control unit (N47) ESP:
  • Steering angle sensor (N49)

Instrument cluster (A1)
Fuel pump relay (F1 k3)
CC [TPM] switch (S40)
M111: HFM-SFI [HFM] control unit (N3/4)
M112/113: ME control unit (N3/10)		  
F23 - - - Spare -
F24 58R 0.8 mm 2 blue 0.8 mm 2 green
1.0 mm 2 blue
1.0 mm 2 green
1.0 mm 2 green		 Circuit 58R interior connector sleeve (Z52/4):
  • Trailer hitch connector (X52)

Right front lamp unit (E2):
  • Right standing and parking lamp (E2e3)

Right taillamp (E4):
  • Right taillamp and parking lamp (E4e2)

Right side-marker lamp (E2e6)		 7.5
F25 R   1.0 mm 2 pink
0.5 mm 2 pink		 Right front lamp unit (E2):
  • Right turn signal lamp (E2e5)

Right taillamp (E4):
  • Right turn signal lamp (E4e1)

Right additional turn signal lamp (E22/2)
Traction systems control unit (N47)
Interior connector sleeve (circuit R) (Z53/5):
  • Trailer hitch connector (X52)

Instrument cluster (A1):
  • Right turn signal indicator lamp (A1e2)
 7.5
F26 15   4.0 mm 2 pink/red
2.5 mm 2 black/ yellow
4.0 mm 2 black/ yellow		 Circuit 15 (fused) connector sleeve (Z3/29):
  • Ignition coils, engine 111
  • Ignition coils, engine 112
  • Ignition coils, engine 113
 15
F27 30   1.0 mm 2 red Traction systems control unit (N47) 40
F28 15R/30   3.0 mm 2 white Heated seats interior connector sleeve (Z53/8):
Left/right heated seat supply:
  • Heated seat relay, stage 1 (K59)
  • Heated seat relay, stage 2 (K59/1)
  • Left front seat heated cushion (R13/1)
  • Right front seat heated cushion (R13/3)
  • Left front backrest heated cushion (R13/2)
  • Right front backrest heated cushion (R13/4)
 20
F29 15R/30   2.0 mm 2 orange
1.0 mm 2 orange		 Center console switch group (S21):
  • Right front window switch (S21s2)
    • Right front power window motor (M10/4)
  • Left rear window switch (S21s3)

Rear center console power window switch combination (S21/15):
  • Left rear power window switch (S21/15s1)
    • Left rear power window motor (M10/5)

Right front power window relay (F1 k16)		 30
F30 15R/30   2.0 mm 2 orange
1.0 mm 2 gray		 Center console switch group (S21):
  • Left front window switch (S21s1)
  • Right rear window switch (S21s4)

Rear center console power window switch combination (S21/15):
  • Right rear power window switch (S21/15s2)

Left front power window relay (F1k18)		 30
F31 30   0.5 mm 2 blue
0.8 mm 2 blue		 Center console switch group (S21):
  • Up/down outside mirror adjustment (S21s6)
  • Left/right outside mirror adjustment (S21s7)
  • Left/right outside mirror selection (S21s8)

Pivot window cockpit connector sleeve (Z50/13):
  • Rear vent window:
    • Left vent window switch (S21/13)
    • Right vent window switch (S21/14)

Tilting/sliding roof switch (S13/2)		 15
Fuse Circuit Color of unfused wire Color of unfused wire Fused function Socket Rating in amperes (A)
F32 15R/30   2.0 mm 2 orange Right front seat adjustment switch (S23)
Right front seat adjustment motor group (M26)
  • Fore/aft motor (M26m1)
  • Rear up/down motor (M26m2)
  • Front up/down motor (M26m3)
  • Backrest fore/aft motor (M26m5)
   30
F33 15R/30   2.0 mm 2 orange Left front seat adjustment switch (S22)
Left front seat adjustment motor group (M25):
  • Fore/aft motor (M25m1)
  • Rear up/down motor (M25m2)
  • Front up/down motor (M25m3)
  • Backrest fore/aft motor (M25m5)
   30
F34 56L   1.0 mm 2 pink
0.5 mm 2 pink		 Left front lamp unit (E1):
  • Left low beam (E1e2)

Electric headlamp range adjustment selector wheel (S1/1)
  • Left headlamp range adjustment motor (E1m1)
  • Right headlamp range adjustment motor (E2m1)
   7.5
F35 56R   1.0 mm 2 pink Right front lamp unit (E2):
Right low beam (E2e2)		   7.5
F36 30   3.0 mm 2 pink Rear window heater   25
F37 30   1.0 mm 2 orange: Fanfare horns:
  • Two-tone signaling system (H1)
   20
F38 30   1.0 mm 2 green Fuel pump with fuel level sensor (M3/3)   20
F39 - - - Spare - -
F40 30   4.0 mm 2 red Vacuum pump (engine 612.963)   25
F41 30   1.0 mm 2 white Circulating pump relay (F1k19)
Right engine compartment connector sleeve (engine coolant pump/cooling fan electric box) (Z57/2):
  • Coolant circulation pump (M13)
  • Module box blower motor (M2/2)

On diesel:
Heater booster
Stationary heater		   25
Fuse Circuit Color of unfused wire Color of unfused wire Fused function Socket Rating in amperes (A)
F42 30   0.8 mm 2 white
1.0 mm 2 white		 Central locking:
  • Left front door CL [ZV] motor (M14/6)
  • Right front door CL [ZV] motor (M14/5)

Interior connector sleeve (central locking motor 01) (Z53/1):
  • Rear-end door CL [ZV] motor (M14/7)
  • Left rear door CL [ZV] motor (M14/8)
  • Right rear door CL [ZV] motor (M14/9)
  • Fuel filler flap CL [ZV] motor (M14/10)
   20
F43 30   5.0 mm 2 white Blower motor relay (F1 k21)
Blower motor (M2)		   30
F44 30   2.0 mm 2 green Engine fan stage 1 relay (F1 k26)
Left engine compartment connector sleeve (fan) (Z56/2)
  • Left additional fan (M4m1)
  • Right additional fan (M4m2)
   30
F45 30   2.5 mm 2 red/white Electric air pump (M33)   40
F46 58NS   0.8 mm 2 light brown
1.0 mm 2 light brown		 Up to 30.11.1999
Rear fog lamp cockpit connector sleeve (Z50/10):
  • Left rear fog lamp (E3e5)
  • Right rear fog lamp (E4e5)

Trailer hitch connector (X52)		   7.5
F46 58NS   1.0 mm 2 blue
0.5 mm 2 blue		 As Of 01.12.1999
Rear fog lamp interior connector sleeve (Z52/8):
  • Left rear fog lamp (E3e5)
  • Right rear fog lamp (E4e5)
  • Double switch combination (S97/6) (rear fog lamp diode)
   7.5
F47 58N   1.0 mm 2 gray
1.0 mm 2 gray		 Auxiliary headlamp connector sleeve (in right of engine compartment) (Z56/4):
Left front lamp unit (E1):
  • Left front fog lamp (E1e4)
  • Left additional headlamp high beam (E1e7), right additional headlamp high beam (E2e7) Right front headlamp unit (E2)
  • Right front fog lamp (E2e4)
   15
F48 30   1.0 mm 2 white Alarm signal horn (H3)   20
scientia non olet · About LEMON Manuals