LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2000 >> CL500 >> Repair and Diagnosis >> Restraints >> Seat Belts >> Seats, Restraint Systems -- Testing & Repair -- 215 & 220 Chassis >> Testing & Repair >> Remove/install airbag unit on the steering wheel - AR91.60-P-0660M

Remove/install airbag unit on the steering wheel - AR91.60-P-0660M

MODEL 215, 220 

Shown on model 220 

Fig 1: Identifying Airbag Unit On Steering Wheel Remove/Install Components - Shown On Model 220
G04851883
REMOVINGINSTALLING Remove/install     
DANGER Risk of injury  caused by performing testing or repair work on airbag or emergency tensioning retractor units. Store airbag units with deployment side facing up; do not expose to temperatures greater than 100 °C. When working on these units, disconnect the power supply. AS91.00-Z-0001-01A
NOTES Assessment of airbag and belt tensioner units in accident vehicles   AH91.00-P-0006-01B
NOTES Notes on performing repair, body work and welding on vehicles with airbags and ETR units   AH91.00-P-0002-01M
IMPORTANT Legal regulations on handling and storing airbags and emergency tensioning retractors   AH91.00-P-0004-01A
1 Withdraw ignition key    
2 Remove two screws (arrow) IMPORTANT At the same time hold the airbag unit.  
    SPECIAL TOOL Figure
    SPECIAL TOOL Fig 2
    TORQUE SPECIFICATION *BA91.60-P-1001-01A 
3 Lift off the airbag unit from the steering wheel and detach the plug-in connector from the squib on the gas generator SPECIAL TOOL  
    IMPORTANTInstallation:  connector must be heard to engage when being plugged in. Fig 4
4 Remove airbag unit from steering wheel If the airbag unit is replaced, the defective unit must be disposed of correctly: ↓  
REFER TO FORMS Notes on disposing of airbag and emergency tensioning retractor units   OS91.00-P-0001-01A
  Make airbag units unusable   AR91.60-P-0611A 
5 Install in the reverse order IMPORTANTInstallation:  The steering wheel must always be replaced after the driver airbag unit has been triggered.  
6 Check the automatic resetting of the combination switch    
7 Read out fault memory    
REFER TO SELF-DIAGNOSTIC SYSTEMS Connect STAR DIAGNOSIS and read out fault memory   AD00.00-P-2000-04A
    STAR DIAGNOSIS diagnosis system *WH58.30-Z-1048-13A 
TORQUE SPECIFICATION AIRBAG CHART

Number Designation Model 215 Model 220
BA91.60-P-1001-01A Bolt, airbag to steering wheel Nm 8 8
Fig 2: Identifying Screwdriver Bit (126 589 00 10 00)
G04851884
Fig 3: Identifying Torque Wrench (001 589 66 21 00)
G04851885
Fig 4: Identifying Removal Lever (203 589 04 33 00)
G04851886
COMMERCIALLY AVAILABLE TOOLS

Number Designation
WH58.30-Z-1048-13A STAR DIAGNOSIS diagnosis system, Compact Passenger Car 6511 1801 00