LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 1999 >> SL600 >> Repair and Diagnosis >> Suspension >> Rear Suspension >> Suspension -- 129 Chassis >> Testing & Repair >> Draining and filling pressure oil system at front and rear axle - AR32.31-P-0630A

Draining and filling pressure oil system at front and rear axle - AR32.31-P-0630A

MODEL 129 with CODE (216c) Adaptive damping system (ADS II) with electronic level control 

Fig 1: Identifying Pressure Oil System Draining And Filling Components
G04684871
REMOVING Emptying     
NOTES General notes for working on vehicles with level control / ADS All models with Code 216b, 216c, 217a, 480 AH32.00-P-0002-01A 
1 Press level adjustment switch (S77/1) into the "lock out" position IMPORTANT ADS suspension MIL (A1e27) illuminated.  
2 Raise vehicle. IMPORTANT Engine must be switched off.  
IMPORTANT   Only when "Removing/installing valve unit", empty/fill the pressure oil system at the front or rear axle.
Otherwise depending on the scope of the work only empty/fill the pressure oil system at the front or rear axle.
 
3 Front axle  :
Mount oil drain hose (061) on the oil drain plug (56a) on distributor (56)
IMPORTANT Lower engine cover removed  
4 Rear axle  :
Mount oil drain hose (061) on the oil drain plug (57a) on distributor (57)
IMPORTANT Cover in the area of the fuel pump assembly / rear axle removed.  
DANGER Risk of injury  to skin or eyes from hydraulic fluid spraying out under pressure. Risk of poisoning  from swallowing hydraulic fluid. Release the pressure in the hydraulic system completely before starting any work on the system. Wear protective clothing and safety glasses. AS00.00-Z-0013-01A
5 Open oil drain plug (56a or 57a) slowly, collect the oil in a clean container IMPORTANT The fluid can subsequently be refilled into the system for continued use.  
6 Close oil drain plug (56a or 57a) again. TORQUE SPECIFICATION *BA32.31-P-1002-01A 
    TORQUE SPECIFICATION *BA32.31-P-1001-01A 
INSTALLING Refill     
7 Lower vehicle or vehicle must be on its wheels NOTES At front axle: Position wheels straightahead  
8 Fill reservoir (2) with fluid SPECIAL TOOL Only re-use clean oil!  
    SPECIAL TOOL Funnel Figure
    FLUID SPECIFICATION *BF32.30-P-1001-01A 
IMPORTANT The ignition must have been switched off for at least 60 seconds IMPORTANT Otherwise fault display in ADS system  
DANGER Risk of accident  . Accidents may result if the vehicle starts off unintentionally with the engine running. Risk of injury  as working around the engine during start-up or while running may result in contusions and burns Secure vehicle to prevent it from moving. Wear closed and snug-fitting work clothes.
Do not grasp hot or rotating parts.
AS00.00-Z-0005-01A
9 Start engine and allow to run for approx. 2 minutes at moderate speed. The system bleeds itself automatically.
NOTES Ensure that the reservoir contains sufficient fluid. The pump must never be allowed to draw in air.
 
10 Switch off level adjustment switch (S77/1) "lock out" position IMPORTANT Warning lamp (A1e27) ADS suspension goes out.
IMPORTANT Should the filling operation last longer than 5 minutes, the control module switches off the valves for 5 minutes (overload protection).
 
11 Switch off engine    
12 Check and correct oil level in oil reservoir FLUID SPECIFICATION
IMPORTANT Level control switch (S77/1) is the "Normal level" position (indicator in switch: OFF  ).
Oil level between the "min" and "max" marks. The vehicle must be unladen
AP32.30-P-3211BA 
13 Conduct a road test IMPORTANT For complete bleeding of the hydraulic system upon completion of the filling operation a test drive should be carried out on rough terrain. In the process carry out level control high level stage 1  and high level stage 2  . Then carry out oil level check at "Normal level" again  
TORQUE SPECIFICATION DISTRIBUTOR FITTING

Number Designation Model 129 with electronic level control system / ADS II
BA32.31-P-1001-01A Oil drain plug on rear axle distributor (guide value) M10x1 NM 14
BA32.31-P-1002-01A Oil drain plug on front axle distributor (guide value) M10x1 NM 14
FLUID SPECIFICATION LEVEL CONTROL SYSTEM

Number Designation Model 129 with ADS and level control/ASD
BF32.30-P-1001-01A Filling quantity Level control, when refilling system Liter ≈ 4-4,5
Specifications for Operating Fluids Sheet BB00.40-P-0343-00A
Sheet -
Fig 2: Identifying Funnel (126 589 12 63 00)
G04684872
Fig 3: Identifying Ring Wrench (116 589 00 17 00)
G04684873