Extended vehicle network (EVN) diagnosis troubleshooting diagram wiper system - AD00.19-P-5000A
MODEL 202 as of 1.6.97, 208, 210.081 /281, 210 as of 1.3.97
| Extended vehicle network (EVN) diagnosis, previous knowledge | AD00.19-P-2000A | ||
| Troubleshooting | |||
| Complaint | Possible cause | Notes | Remedy/Test step |
| Wiper system inoperative | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-48A | |
| Combination switch (S4) | AD00.19-P-6000-49A | ||
| Wiper stage 1 relay (K40/2k1) | AD00.19-P-6000-50A | ||
| Wiper stage 2 relay (K40/2k2) | AD00.19-P-6000-51A | ||
| Electronic ignition switch control module (N73) | AD00.19-P-6000-52A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-53A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-54A | ||
| Driver-side fuse and relay module (K40/2) | AD00.19-P-6000-55A | ||
| AD00.19-P-6000-56A | |||
| AD00.19-P-6000-57A | |||
| AD00.19-P-6000-58A | |||
| AD00.19-P-6000-59A | |||
| AD00.19-P-6000-60A | |||
| AD00.19-P-6000-61A | |||
| AD00.19-P-6000-62A | |||
| Windshield wiper inoperative when washer function is operated | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-48A | |
| Combination switch (S4) | AD00.19-P-6000-49A | ||
| Electronic ignition switch control module (N73) | AD00.19-P-6000-50A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-51A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-52A | ||
| AD00.19-P-6000-54A | |||
| AD00.19-P-6000-61A | |||
| AD00.19-P-6000-63A | |||
| Wiper system, Intermittent inoperative | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-48A | |
| Electronic ignition switch control module (N73) | AD00.19-P-6000-49A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-50A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-51A | ||
| Windshield washer relay (K40/2k3) | AD00.19-P-6000-52A | ||
| Driver-side fuse and relay module (K40/2) | AD00.19-P-6000-54A | ||
| AD00.19-P-6000-58A | |||
| AD00.19-P-6000-62A | |||
| Wiper system, stage 1 inoperative | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-48A | |
| Combination switch (S4) | AD00.19-P-6000-49A | ||
| Electronic ignition switch control module (N73) | AD00.19-P-6000-50A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-51A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-52A | ||
| Wiper stage 1 relay (K40/2k1) | AD00.19-P-6000-54A | ||
| Driver-side fuse and relay module (K40/2) | AD00.19-P-6000-59A | ||
| AD00.19-P-6000-62A | |||
| Wiper system, stage 2 inoperative | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-48A | |
| Combination switch (S4) | AD00.19-P-6000-49A | ||
| Electronic ignition switch control module (N73) | AD00.19-P-6000-50A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-51A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-52A | ||
| Wiper stage 2 relay (K40/2k2) | AD00.19-P-6000-55A | ||
| Driver-side fuse and relay module (K40/2) | AD00.19-P-6000-59A | ||
| AD00.19-P-6000-62A | |||
| Wiper system cannot be switched off when ignition is ON | Wiper motor (M6/1) Driver-side signal-acquisition and actuation module (SAM) (N10/1) Driver-side fuse and relay module (K40/2) |
AD00.19-P-6000-53A | |
| Rain sensor (B38) inoperative | Overhead control panel control module (N70) | AD00.19-P-6000-64A | |
| Electronic ignition switch control module (N73) | AD00.19-P-6000-65A | ||
| Driver-side signal-acquisition and actuation module (SAM) (N10/1) Wiper stage 1 relay (K40/2k1) Driver-side fuse and relay module (K40/2) |
AD00.19-P-6000-66A | ||
| Rear wiper system does not function when operated (models 202/210 T-model only) | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-67A | |
| Rain sensor (B38) Rear wiper switch (S6/1s4) Rear window wiper motor (M6/4) Driver-side signal-acquisition and actuation module (SAM) (N10/1) PSE (A37) |
AD00.19-P-6000-70A | ||
| Rear wash does not function when operated (models 202/210 T-model only) | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-52A | |
| Rear wiper switch (S6/1s4) | AD00.19-P-6000-56A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-68A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-69A | ||
| Windshield washer pump (M5/1), model 210 | AD00.19-P-6000-70A | ||
| Rear window washer pump (M5/3), model 202 |
|||
| Headlamp cleaning system does not function when operated | Voltage supply, terminal 15R, 31 | AD00.19-P-6000-52A | |
| HCS switch (S4/1) | AD00.19-P-6000-57A | ||
| Driver-side signal-acquisition and actuation | AD00.19-P-6000-71A | ||
| module (SAM) (N10/1) | AD00.19-P-6000-72A | ||
| Headlamp washer pump (M5/2) | AD00.19-P-6000-73A | ||
| Headlamp cleaning system | Combination switch (S4) | AD00.19-P-6000-52A | |
| Headlamp wiper motors do not function when operated (model 202 only) | Driver-side signal-acquisition and actuation | AD00.19-P-6000-57A | |
| module (SAM) (N10/1) | AD00.19-P-6000-71A | ||
| Left/right headlamp wiper motor (M6/2, M6/3) |
AD00.19-P-6000-72A | ||
| AD00.19-P-6000-73A |