Extended vehicle network (EVN) diagnosis operational check actual values wiper system - AD00.19-P-3000A
MODEL 202 as of 1.6.97, 208, 210.081 /281, 210 as of 1.3.97
| Extended vehicle network (EVN) diagnosis, previous knowledge | AD00.19-P-2000A | |||||
| I | Fuses in order. | |||||
| II | Battery voltage >11 V | |||||
| III | Connect Hand-Held Tester to data link connector (DTC readout) (X11/4) in accordance with connecting diagram | AD00.00-P-1000AZ | ||||
| IV | Voltage supply of control modules and CAN data buses in order | AD00.19-P-6000A | ||||
| V | All CAN data buses connected | |||||
| Function check | ||||||
| Test step/ Scope of test |
Operation/Requirement | Specified value | Possible cause/Remedy | |||
| 1 | EZS | Ignition: Position 1 | ON | AD00.19-P-6000-03A | ||
| Terminal 15R | ON | OFF | AD00.19-P-6000-57A | |||
| OFF | ||||||
| 2 | EZS | Ignition: Position 2 | ON | AD00.19-P-6000-02A | ||
| Terminal 15 | ON | OFF | ||||
| OFF | ||||||
| 3 | DBE | 9.5 - 15.5 | AD00.19-P-6000-01A | |||
| Undervoltage | ||||||
| 4 | DBE | 9.5 - 15.5 | AD00.19-P-6000-01A | |||
| Overvoltage | ||||||
| 5 | EZS | Ignition: ON | INTERMITTENT | AD00.19-P-6000-62A | ||
| Windshield wiper, intermittent Actuation of electronic ignition switch control module (N73) by combination switch (S4) |
Combination switch, intermittent | |||||
| ON | ||||||
| 6 | EZS | Ignition: ON | STAGE 1 | AD00.19-P-6000-62A | ||
| Windshield wiper, stage 1 Actuation of electronic ignition switch control module (N73) by combination switch (S4) |
Combination switch, stage 1 | |||||
| ON | ||||||
| 7 | EZS | Ignition: ON | STAGE 2 | AD00.19-P-6000-62A | ||
| Windshield wiper, stage 2 Actuation of electronic ignition switch control module (N73) by combination switch (S4) |
Combination switch, stage 2 | |||||
| ON | ||||||
| 8 | EZS | Ignition: ON | YES | AD00.19-P-6000-63A | ||
| Windshield wiper wash Actuation of electronic ignition switch control module (N73) by combination switch (S4) |
Combination switch, wash | ON | ||||
| ON | ||||||
| OFF | ||||||
| 9 | SAM | Ignition: ON | STAGE 1 | AD00.19-P-6000-58A | ||
| Actuation of wiper stage 1 relay (K40/2k1) by driver-side signal acquisition and actuation module (SAM) (N10/1) |
HHT: Actuation menu | Wiper motor operates | AD00.19-P-6000-59A | |||
| Press button "F2" | ||||||
| 10 | SAM | Ignition: ON | STAGE 2 | AD00.19-P-6000-59A | ||
| Actuation of wiper stage 2 relay (K40/2k2) by driver-side signal-acquisition and actuation module (SAM) (N10/1) |
HHT: Actuation menu | Wiper motor operates | AD00.19-P-6000-60A | |||
| Press button "F2" | ||||||
| 11 | SAM | Ignition: ON | ON | AD00.19-P-6000-61A | ||
| Actuation of windshield washer relay, stage 1 (K40/2k3) by driver-side signal-acquisition and actuation module (SAM) (N10/1) | HHT: Actuation menu | OFF | ||||
| Press button "F2" | Washer pump operates | |||||
| 12 | SAM | Ignition: ON | ON | AD00.19-P-6000-68A | ||
| Rear wiper switch (S6/1s4) Models 202/210 T-model only |
S6/1s4 | OFF | ||||
| Operate WIPE | ||||||
| do not operate | ||||||
| 13 | SAM | Ignition: ON | ON | AD00.19-P-6000-68A | ||
| Rear wiper switch (S6/1s4) Models 202/210 T-model only |
S6/1s4 | OFF | ||||
| Operate WIPE | ||||||
| do not operate | ||||||
| 14 | PSE | Ignition: ON | ON | AD00.19-P-6000-67A | ||
| Rear window wiper motor (M6/4) Models 202/210 T-model only |
HHT: Actuation menu | OFF | ||||
| Press button "F2" | Rear window wiper motor operates | |||||
| Press button "F3" | ||||||
| 15 | SAM | Ignition: ON | ON | AD00.19-P-6000-69A | ||
| Actuation of windshield washer relay (K40/2k3) by driver-side signal-acquisition and actuation module (SAM) (N10/1) Model 202 T-model Rear window washer pump (M5/3), Model 210 T-model Windshield washer pump (M5/1) |
HHT: Actuation menu | OFF | ||||
| Press button "F2" | Washer pump operates | |||||
| 16 | SAM | Ignition: ON | ON | AD00.19-P-6000-66A | ||
| Headlamp cleaning system Actuation of driver-side signal-acquisition and actuation module (SAM) (N10/1) by HCS switch (S4/1) |
S4/1: ON | OFF | ||||
| 17 | SAM | Ignition: ON | ON | AD00.19-P-6000-72A | ||
| Headlamp cleaning system Actuation of HCS pump relay (K40/2k5) by driver-side signal-acquisition and actuation module (SAM) (N10/1) |
Terminal 58d On (model 202 only) | OFF | ||||
| HCS switch | ||||||
| ON | ||||||
| 18 | SAM | Ignition: ON | ON | AD00.19-P-6000-72A | ||
| Headlamp washer pump (M5/2) | HHT: Actuation menu | OFF | ||||
| Press button "F2" | Washer pump operates | |||||