Check all visible parts for leaks and damage - AP00.20-P-0053BA

WARNING: This page does not describe the selected car, but rather 42 other vehicles, including the 1999 Mercedes-Benz S600, 1999 Mercedes-Benz S500, 1999 Mercedes-Benz S420, 1999 Mercedes-Benz S320, and 1999 Mercedes-Benz CL600. However, it is still accessible from the selected car via links, so may be relevant.

MODEL 124, 129, 140, 168, 170, 202, 203, 208, 209, 210

MODEL 211.004 /006 /007 /008 /016 /020 /022 /023 /026 /028 /029 /041 /042 /052 /054 /056 /061 /065 /070 /072 /076 /077 /080 /082 /083 /084 /087 /089 /090 /092 /206 /208 /216 /220 /222 /223 /226 /241 /242 /254 /256 /261 /265 /270 /272 /276 /277 /280 /282 /283 /284 /287 /289 /290 /292 /606 /608 /616 /620

MODEL 215.373 /374 /375 /378

MODEL 230.456 /467 /471 /472 /474 /475

MODEL 220.025 /026 /028 /063 /065 /067 /070 /073 /074 /075 /083 /084 /087 /125 /126 /128 /163 /165 /167 /170 /173 /174 /175 /178 /183 /184 /187 /875 /878

	Removing
	Risk of death caused by vehicle slipping or toppling off of the lifting platform.	Align vehicle between columns of vehicle lift and position four support plates at vehicle lift support points specified by vehicle manufacturer.	AS00.00-Z-0010-01A
1.1	Remove lower engine compartment paneling	Vehicles with gasoline engine
+		Model 124	wh6190pkw0000x
-		Model 140	wh6190pkw0000x
	Remove and install bottom engine compartment paneling	Model 168	AR61.20-P-1105GC
		Model 170	AR61.20-P-1105A
		Model 203, 209	AR61.20-P-1105P
		Model 129, 202, 208, 210	AR61.20-P-1105AB
		Model 211	AR61.20-P-1105T
		Model 215, 220	AR61.20-P-1105M
		Model 230	AR61.20-P-1105R
1.2	Remove bottom sections of soundproofing capsule	Vehicles with diesel engines
+		Model 124	wh9490pkw0000x
-		Model 140	ra94001405305x
	Remove/install bottom parts of soundproofing	Model 168	AR94.30-P-5300GD
		Model 202	AR94.30-P-5300A
		Model 203, 209	AR94.30-P-5300P
		Model 210	AR94.30-P-5300AB
		Model 211	AR94.30-P-5300T
		Model 220	AR94.30-P-5300M
	Checking
2	Check lower engine compartment panelings or lower parts of soundproofing for traces of fluid	If traces of fluid are determined (e.g. oil), then determine the cause and rectify as a separate job.
3	Check for leaks and condition	Check following major assembly: Engine Automatic transmission manual transmission Automated manual transmission (Sequentronic) Rear axle Pressure oil pump suspension elements Rubber boots on rear and front axle shafts Transfer case, front axle gear (for 4MATIC only)
4	Check lines and hoses for leaks and condition, pay attention to chafing points and routing	Check following major assembly: Radiator Fuel system Exhaust system Clutch operator Automatic transmission Automated manual transmission (Sequentronic) Power steering Level control ABC system Brake System ABS, ASR, ESP, SBC, ABR Ring cylinder on rear axle center assembly (for automatic locking differential only)
	Install
5.1	Install lower engine compartment paneling	Vehicles with gasoline engine Install lower engine compartment paneling after all maintenance operations have been completed.
+		Model 124.0/2	wh6190pkw0000x
-		Model 140.0	wh6190pkw0000x
	Remove and install bottom engine compartment paneling	Model 168	AR61.20-P-1105GC
		Model 170	AR61.20-P-1105A
		Model 203, 209	AR61.20-P-1105P
		Model 129, 202, 208, 210	AR61.20-P-1105AB
		Model 211	AR61.20-P-1105T
		Model 215, 220	AR61.20-P-1105M
		Model 230	AR61.20-P-1105R
5.2	Install bottom section of soundproofing	Vehicles with diesel engines Do not install bottom sections of soundproofing until all maintenance work has been completed.
+		Model 124	wh9490pkw0000x
-		Model 140	ra94001405305x
	Remove/install bottom parts of soundproofing	Model 168	AR94.30-P-5300GD
		Model 202	AR94.30-P-5300A
		Model 203, 209	AR94.30-P-5300P
		Model 210	AR94.30-P-5300AB
		Model 211	AR94.30-P-5300T
		Model 220	AR94.30-P-5300M