Pre-Delivery Inspection Table: Exterior
WARNING: This page is about a different car, the 2020 Mazda CX-30. However, it is still accessible from the selected car via links, so may be relevant.
INSPECT and ADJUST, if necessary, the following items to specification:
- REMOVE all protective wrap, covers, and window stickers
- Unless the vehicle is scheduled for display or immediate delivery, do not remove the exterior protective film or interior protective covering during inspection
- Glass, exterior bright metal and paint for damage
- Convertible top for damage (with convertible top)
- Power retractable hardtop for damage (with power retractable hardtop)
- Retractable fastback for damage (with retractable fastback)
- Door and liftgate* operation (Open/Close)
- All weather strips for damage or detachment
- Security/keyless entry devices (Doors locking/unlocking by transmitter)*
- Advanced keyless entry (Doors locking/unlocking by request switches)*
- Operation of hood release and lock, trunk release*, and fuel-filler lid opener
- Pour one bottle of deposit cleaner into the fuel tank (Specified countries only)
- Refuel the vehicle after adding the deposit cleaner or inform the customer to do so immediately
- For details on the specified countries, please refer to the service information
Under hood-engine off
INSPECT and ADJUST, if necessary, the following items:
- INSTALL Fuses for accessories
- Room 25A fuse (Relay and fuse block F27)
- Fuel, engine coolant, and hydraulic lines, fittings, connections, and components for leaks
- Engine oil level
- Brake/clutch fluid level
- Windshield washer reservoir fluid level
- Radiator/Water-cooled charge air cooler* coolant level (for SKYACTIV-D 1.5)
- Radiator coolant level (except for SKYACTIV-D 1.5)
- Tightness of battery terminals, electrolyte level and voltage (12.4 V)
- Check the electrolyte specific gravity in case models with i-stop system or i-ELOOP*
Record the voltage and electrolyte specific gravity in the table below.
Judgment Criteria
- If the cell with the lowest specific gravity is less than 1.17, replace the battery
- If the cell with the lowest specific gravity is 1.17 or more, recharge the battery, after charging if the cell with the lowest specific gravity is less than 1.25, replace the battery.
Please refer to the Service-Information (E039/12A) to get the detail battery inspection procedure.
| Record Battery Voltage/Electrolyte specific gravity | ||||||
|---|---|---|---|---|---|---|
| Open circuit voltage (V) | V/(after charge V) | |||||
| Specific Gravity | No. 1 | No. 2 | No. 3 | No. 4 | No. 5 | No. 6 |
| Before charging | ||||||
| After charging | ||||||