SUZUKI (1995-04)

WARNING: Accidental air bag deployment is possible. Personal injury may result. Avoid area near steering wheel and instrument panel even if air bags have deployed. Dual-stage air bag modules may be present that could contain an undeployed stage. When disposing of a deployed dual-stage air bag, always treat it as a "live" module. See appropriate AIR BAG RESTRAINT SYSTEMS article.

APPLICATION - SUZUKI

Make/Model	Year	Location	Table
Aerio	2002-04	D-P	Suzuki-1
Esteem	1995-02	D-P	Suzuki-1
Forenza	2004	D-P2	Suzuki-2
Sidekick	1996-98	D-P	Suzuki-1
Swift	1995-01	D-P	Suzuki-1
Verona	2004	D-P2, SI	Suzuki-2
Vitara & Grand Vitara	1999-04	D-P	Suzuki-1
XL7	2004	D-P2	Suzuki-1
	2001-04	D-P	Suzuki-1
X90	1996-98	D-P	Suzuki-1

D-P: Driver's & Passenger's Side
D-P2: Driver's & Passenger's Side (Dual-Stage)
DS: Driver's Side
HI: Head Impact
KI: Knee Impact
SI: Side Impact
PS2: Passenger's Side (Dual-Stage)

Suzuki-1

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; Sensing & Diagnostic Module (SDM); Forward sensors (if equipped); Deployed seat belt pretensioners (if equipped);

AIR BAG warning light operation; Combination switch assembly & contact coil; Forward sensors⁽¹⁾; Instrument panel reinforcement; Knee bolsters; Seat belts & mounting points; SDM & SDM bracket; Steering column bracket; Steering column & shaft joints; Steering wheel; Wiring harness; Air bag module(s); Sensing & Diagnostic Module (SDM);

If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring harness repairs.;

⁽¹⁾	Swift and XL-7.

Suzuki-2

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; Clockspring; Sensing & Diagnostic Module (SDM)⁽¹⁾; SIR wiring harness; Deployed seat belt pretensioners (if equipped);

AIR BAG warning light operation; Instrument panel reinforcement; Knee bolsters; Seat belts & mounting points; SDM & SDM bracket; Steering column bracket; Steering column & shaft joints; Steering wheel; SIR wiring harness; Air bag module(s); Sensing & Diagnostic Module (SDM);

If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring harness repairs.;

⁽¹⁾	SDM can sustain 5 seat belt pretensioner deployments or one air bag module deployment before replacement is required