P1408 - EGR Flow Out Of Self Test Range

WARNING: This page does not describe the selected car, but rather 31 other vehicles, including the 2017 Lincoln Navigator, 2017 Lincoln MKZ, 2017 Lincoln MKX, 2017 Lincoln MKT, and 2017 Lincoln MKC. However, it is still accessible from the selected car via links, so may be relevant.

P1408 - EGR FLOW OUT OF SELF TEST RANGE

Description:	This test is carried out during the key ON, engine running (KOER) on demand self-test only. The EGR system is commanded on at a fixed engine speed. This DTC sets when the measured EGR flow falls above or below the required calibration.
Possible Causes:	For electric EGR (EEGR) system, EEGR valve stuck open or closed EEGR connector not seated correctly EEGR stepper motor VPWR circuit open EGRMC circuit open EGRMC circuit short to voltage EGRMC circuit short to ground Vacuum signal to manifold absolute pressure (MAP) sensor restricted or leaking Mass airflow (MAF) sensor signal erroneous Carbon build up in the EEGR valve seat area
Diagnostic Aids:	Use the output state control function of the scan tool and monitor the MAP and the EGRMDSD PIDs while commanding the EEGR on. If EGR is introduced into the engine at idle, the RPM drops or stalls out.
Application	Key On Engine Off	Key On Engine Running	Continuous Memory
All	GO to Pinpoint Test KD .