DTC P0D5E-00: Hybrid/EV Battery Charger Hybrid/EV System Discharge Time Too Long [08/2023 - ]: Procedure

Pre-procedure1

1. None.

   Procedure1

2. Check for DTCs.

   Powertrain > Hybrid Control > Trouble Codes 

   Powertrain > HV Battery > Trouble Codes 

   Powertrain > Plug-in Control > Trouble Codes 

   Result

   Result	Proceed to
   P0D5E-00 only is output, or DTCs except the ones in the table below are also output.	A
   DTCs of hybrid control system in the tables below are output.	B
   DTCs of hybrid battery system in the tables below are output.	C
   DTCs of plug-in charge control system in the tables below are output.	D

   Malfunction Content	System	Relevant DTC
   Microcomputer malfunction	Hybrid control system	P0606-47	Hybrid/EV Powertrain Control Module Processor Watchdog / Safety MCU Failure
   		P0606-87	Hybrid/EV Powertrain Control Module Processor to Monitoring Processor Missing Message
   		P060A-47	Hybrid/EV Powertrain Control Module Monitoring Processor Watchdog / Safety MCU Failure
   		P060A-87	Hybrid/EV Powertrain Control Module Processor from Monitoring Processor Missing Message
   		P1C9E-9F	Hybrid/EV System Reset Stuck Off
   	Plug-in charge control system	P060B-49	Plug-in Control Module A/D Processing Internal Electronic Failure
   		P0E5E-87	Plug-in Control Module Processor from Hybrid/EV Battery Charger Control Module Processor Missing Message
   		P1C1F-49	Hybrid/EV Battery Charger Control Module A/D Processing Internal Electronic Failure
   Communication system malfunction	Hybrid control system	P0A1F-94	Hybrid/EV Battery Energy Control Module Unexpected Operation
   		U0111-87	Lost Communication with Hybrid/EV Battery Energy Control Module "A" Missing Message
   		U019B-87	Lost Communication with Hybrid/EV Battery Charger Control Module Missing Message
   	Plug-in charge control system	U1150-87	Lost Communication with Hybrid Powertrain Control Module (Hybrid/EV Battery Local Bus) Missing Message
   Sensor and actuator circuit malfunction	Plug-in charge control system	P0D4C-12	Hybrid/EV Battery Charger Hybrid/EV Battery Input Voltage Sensor Circuit Short to Auxiliary Battery
   		P0D4C-14	Hybrid/EV Battery Charger Hybrid/EV Battery Input Voltage Sensor Circuit Short to Ground or Open
   	Hybrid battery system	P0D0A-11	Hybrid/EV Battery Charging System Positive Contactor Control Circuit Short to Ground
   		P0D0A-15	Hybrid/EV Battery Charging System Positive Contactor Control Circuit Short to Auxiliary Battery or Open
   		P0D11-11	Hybrid/EV Battery Charging System Negative Contactor Control Circuit Short to Ground
   		P0D11-15	Hybrid/EV Battery Charging System Negative Contactor Control Circuit Short to Auxiliary Battery or Open
   		P0E6D-11	Hybrid/EV Battery Charging System Precharge Contactor Control Circuit Short to Ground
   		P0E6D-15	Hybrid/EV Battery Charging System Precharge Contactor Control Circuit Short to Auxiliary Battery or Open
   System malfunction	Hybrid control system	P0D4C-1C	Hybrid/EV Battery Charger Hybrid/EV Battery Input Voltage Sensor Voltage Out of Range
   	Plug-in charge control system	P1C26-17	Hybrid/EV Battery Charger Hybrid/EV Battery Input Voltage Sensor Circuit Voltage Above Threshold

   HINT: 

   • P0D5E-00 may be output as a result of the malfunction indicated by the DTCs above.
     1. The chart above is listed in inspection order of priority.
     2. Check DTCs that are output at the same time by following the listed order. (The main cause of the malfunction can be determined without performing unnecessary inspections.)

   Post-procedure1

3. Turn the ignition switch off.

Result: 

A 

REPLACE ELECTRIC VEHICLE CHARGER ASSEMBLY. Refer to  REMOVAL [08/2023 - ] 

Result: 

B 

GO TO DTC CHART (HYBRID CONTROL SYSTEM). Refer to  DIAGNOSTIC TROUBLE CODE CHART [08/2023 - 10/2024]  , or refer to  DIAGNOSTIC TROUBLE CODE CHART [10/2024 - ] 

Result: 

C 

GO TO DTC CHART (HYBRID BATTERY SYSTEM). Refer to  DIAGNOSTIC TROUBLE CODE CHART [08/2023 - ] 

Result: 

D 

GO TO DTC CHART (PLUG-IN CHARGE CONTROL SYSTEM). Refer to  DIAGNOSTIC TROUBLE CODE CHART [08/2023 - ]