LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2024 >> NX 250 FWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 118 (Automatic Transaxle System - Service Information (2 Of 2)) >> Automatic Transaxle Unit >> Reassembly [11/2021 - ] >> Caution / Notice / Hint

Caution / Notice / Hint

WARNING: This page is about a different car, the 2025 Lexus NX 350, 2024 Lexus NX 350, 2023 Lexus NX 350, and 2022 Lexus NX 350. However, it is still accessible from the selected car via links, so may be relevant.

COMPONENTS (REASSEMBLY) 

Fig 1: Automatic Transaxle Unit Reassembly Components With Torque Specifications (1 Of 18)
GTY1065401Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
1 BEARING POSITION - See step  1 - -
2 AUTOMATIC TRANSMISSION CASE STRAIGHT PIN 35101E See step  2 - -
3 COUNTER DRIVEN GEAR FRONT TAPERED ROLLER BEARING (INNER RACE) 41206A See step  3 - -
4 COUNTER DRIVEN GEAR FRONT TAPERED ROLLER BEARING (OUTER RACE) 41206A See step  4 - -
5 COUNTER DRIVEN GEAR REAR TAPERED ROLLER BEARING (INNER RACE) 41206D See step  5 - -
6 COUNTER DRIVEN GEAR REAR TAPERED ROLLER BEARING (OUTER RACE) 41206D See step  6 - -
7 ADJUST FRONT DIFFERENTIAL CASE TAPERED ROLLER BEARING PRELOAD - - - See step  7
8 ADJUST PINION AND COUNTER DRIVEN GEAR TAPERED ROLLER BEARING PRELOAD - - - See step  8
*1 PINION AND COUNTER DRIVEN GEAR SHIM *2 DIFFERENTIAL CASE ASSEMBLY
*3 TRANSAXLE HOUSING *4 AUTOMATIC TRANSAXLE CASE SUB-ASSEMBLY
*5 PINION AND COUNTER DRIVEN GEAR SUB-ASSEMBLY - -
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS - -
Fig 2: Automatic Transaxle Unit Reassembly Components With Torque Specifications (2 Of 18)
GTY1062674Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
9 NO. 1 BREATHER PLUG (ATM) 35104B See step  9 - -
10 NO. 2 TRANSAXLE CASE PLUG 35104R See step  10 - -
11 NO. 1 TRANSAXLE CASE PLUG 35104Q See step  11 - -
12 FRONT DRIVE SHAFT OIL SEAL LH 43420H See step  12 - -
13 MANUAL VALVE LEVER SHAFT OIL SEAL - See step  13 - -
14 NEEDLE ROLLER BEARING - See step  14 - -
*1 O-RING *2 GASKET
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS MP grease
Toyota Genuine Adhesive 1324, Three Bond 1324 or equivalent * Precoated part
Fig 3: Automatic Transaxle Unit Reassembly Components With Torque Specifications (3 Of 18)
GTY1061925Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
15 NO. 2 TRANSAXLE CASE PLUG 35104R See step  15 - -
16 NO. 1 TRANSAXLE CASE PLUG 35104Q See step  16 - -
17 NEEDLE ROLLER BEARING 35605C See step  17 - -
18 DIFFERENTIAL SIDE OIL SEAL 41110G See step  18 - -
19 FRONT TRANSAXLE CASE OIL SEAL 31105D See step  19 - -
*1 GASKET *2 O-RING
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS MP grease
Toyota Genuine Adhesive 1324, Three Bond 1324 or equivalent * Precoated part
Fig 4: Automatic Transaxle Unit Reassembly Components (4 Of 18)
GTY1062394Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
20 1ST AND REVERSE BRAKE PISTON 35623H See step  20 - -
21 1ST AND REVERSE BRAKE RETURN SPRING SUB-ASSEMBLY 35068 See step  21 - -
22 NO. 2 1ST AND REVERSE BRAKE PISTON 35623P - - -
23 2ND BRAKE DISC 35682 See step  23 - -
24 INSPECT CLEARANCE OF B-2 BRAKE - - - See step  24
*1 O-RING *2 SNAP RING
*3 2ND BRAKE FLANGE *4 2ND BRAKE PLATE
• Non-reusable part Toyota Genuine ATF WS
Fig 5: Automatic Transaxle Unit Reassembly Components (5 Of 18)
GTY1062367Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
25 DIRECT CLUTCH DRUM OIL SEAL RING 35653B See step  25 - -
26 C-2 CLUTCH PISTON 35652E See step  26 - -
27 CLUTCH RETURN SPRING SUB-ASSEMBLY 35608N - - -
28 C-2 CLUTCH BALANCER 35698A See step  28 - -
29 NO. 2 CLUTCH DISC 35667B See step  29 - -
30 NO. 1 THRUST BEARING RACE 35786A See step  30 - -
31 THRUST NEEDLE ROLLER BEARING - See step  31 - -
*1 O-RING *2 INTERMEDIATE SHAFT SUB-ASSEMBLY
*3 SNAP RING *4 NO. 2 CLUTCH PLATE
*5 DIRECT CLUTCH FLANGE - -
• Non-reusable part Toyota Genuine ATF WS
MP grease - -
Fig 6: Automatic Transaxle Unit Reassembly Components (6 Of 18)
GTY1061776Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
32 C-2 CLUTCH ASSEMBLY - - - -
33 INSPECT CLEARANCE OF C-2 CLUTCH - - - See step  33
34 NO. 4 PLANETARY CARRIER THRUST WASHER 35729B See step  34 - -
35 REAR PLANETARY GEAR ASSEMBLY 35760 - - -
36 NO. 2 THRUST BEARING RACE 35787C See step  36 - -
37 THRUST NEEDLE ROLLER BEARING - See step  37 - -
38 NO. 3 THRUST BEARING RACE 35788D See step  38 - -
39 REAR PLANETARY SUN GEAR SUB-ASSEMBLY 35707D - - -
40 THRUST BEARING RACE 35789U See step  40 - -
41 THRUST NEEDLE ROLLER BEARING - See step  41 - -
42 NO. 4 THRUST BEARING RACE 35785B See step  42 - -
43 PLANETARY SUN GEAR SUB-ASSEMBLY 35706V - - -
44 NO. 3 PLANETARY CARRIER THRUST WASHER 35739 See step  44 - -
Toyota Genuine ATF WS - -
Fig 7: Automatic Transaxle Unit Reassembly Components With Torque Specifications (7 Of 18)
GTY1062305Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
45 NO. 1 BRAKE DISC 35681C See step  45 - -
46 COUNTER DRIVE GEAR SUB-ASSEMBLY 35704C See step  46 - -
47 INSPECT CLEARANCE OF B-1 BRAKE - - - See step  47
*1 NO. 1 BRAKE PLATE *2 NO. 1 BRAKE FLANGE
*3 SNAP RING *4 O-RING
*5 PINION AND COUNTER DRIVEN GEAR SUB-ASSEMBLY - -
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS Do not apply lubricants to the threaded parts
Fig 8: Automatic Transaxle Unit Reassembly Components With Torque Specifications (8 Of 18)
GTY1062936Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
48 PARKING LOCK SLEEVE 35598 See step  48 - -
49 PARKING LOCK PAWL 35557 See step  49 - -
50 PARKING LOCK PAWL SHAFT 35556 See step  50 - -
51 PARKING LOCK PAWL TORSION SPRING 35557A See step  51 - -
52 MANUAL VALVE LEVER SHAFT SUB-ASSEMBLY 35506 See step  52 - -
53 PARKING LOCK ROD SUB-ASSEMBLY 35501 See step  53 - -
54 MANUAL VALVE LEVER SHAFT RETAINER SPRING 35506J - - -
55 PAWL STOPPER PLATE 35596 - - -
56 MANUAL VALVE LEVER SUB-ASSEMBLY 35505 See step  56 - -
57 MANUAL VALVE LEVER SHAFT SUB-ASSEMBLY 35506 See step  57 - -
*1 O-RING - -
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS - -
Fig 9: Automatic Transaxle Unit Reassembly Components (9 Of 18)
GTY1062327Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
58 NO. 5 THRUST BEARING RACE 35775K See step  58 - -
59 THRUST NEEDLE ROLLER BEARING - See step  59 - -
60 SUN GEAR INPUT HUB SUB-ASSEMBLY 35606M - - -
61 FORWARD CLUTCH PISTON 35612B See step  61 - -
62 FORWARD CLUTCH RETURN SPRING SUB-ASSEMBLY 35603A See step  62 - -
63 NO. 1 CLUTCH BALANCER 35668 See step  63 - -
64 FRONT CLUTCH DISC 35633 See step  64 - -
*1 D-RING *2 CLUTCH DRUM SUB-ASSEMBLY
*3 SNAP RING *4 FORWARD MULTIPLE DISC CLUTCH PLATE
*5 FORWARD CLUTCH FLANGE - -
• Non-reusable part Toyota Genuine ATF WS
Fig 10: Automatic Transaxle Unit Reassembly Components (10 Of 18)
GTY1063133Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
65 INSPECT CLEARANCE OF C-1 CLUTCH - - - See step  65
66 C-1 CLUTCH ASSEMBLY - - - -
67 NO. 6 THRUST BEARING RACE 35776 See step  67 - -
68 THRUST NEEDLE ROLLER BEARING - See step  68 - -
69 FRONT PLANETARY RING GEAR 35743 See step  69 - -
70 REAR INPUT SHAFT OIL SEAL RING 35749B See step  70 - -
71 INPUT SHAFT OIL SEAL RING 35712E See step  71 - -
72 NO. 7 THRUST BEARING RACE 35777 See step  72 - -
73 THRUST NEEDLE ROLLER BEARING - See step  73 - -
74 FRONT PLANETARY GEAR ASSEMBLY 35720 - - -
75 NO. 8 THRUST BEARING RACE 35778 See step  75 - -
76 THRUST NEEDLE ROLLER BEARING - See step  76 - -
77 NO. 9 THRUST BEARING RACE 35779A See step  77 - -
78 PLANETARY SUN GEAR 35719B - - -
79 NO. 2 PLANETARY CARRIER THRUST WASHER 35738 See step  79 - -
*1 FRONT PLANETARY RING GEAR FLANGE *2 SNAP RING
• Non-reusable part Toyota Genuine ATF WS
MP grease - -
Fig 11: Automatic Transaxle Unit Reassembly Components (11 Of 18)
GTY1063165Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
80 INSPECT CLEARANCE OF C-4 CLUTCH - - - See step  80
81 INSPECT CLEARANCE OF C-3 CLUTCH - - - See step  81
82 C-3 AND C-4 CLUTCH ASSEMBLY 34610 - - -
83 PLANETARY CARRIER THRUST WASHER 35737 See step  83 - -
Fig 12: Automatic Transaxle Unit Reassembly Components With Torque Specifications (12 Of 18)
GTY1063051Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
84 FRONT OIL PUMP ASSEMBLY - See step  84 - -
85 MANUAL DETENT SPRING SUB-ASSEMBLY 35409D See step  85 - -
86 OIL PUMP SPROCKET REAR THRUST WASHER 35355 See step  86 - -
87 TRANSMISSION DRIVE CHAIN 35781C See step  87 - -
88 OIL PUMP SPROCKET FRONT THRUST WASHER 35354 See step  88 - -
89 CLUTCH DRUM OIL SEAL RING 35617 See step  89 - -
90 DIFFERENTIAL CASE ASSEMBLY - - - -
*1 TRANSMISSION OIL PUMP DRIVE SPROCKET *2 OIL PUMP DRIVE SHAFT SUB-ASSEMBLY
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS MP grease
Fig 13: Automatic Transaxle Unit Reassembly Components With Torque Specifications (13 Of 18)
GTY1061840Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
91 TRANSMISSION LUBE APPLY TUBE 35847C See step  91 - -
92 DIFFERENTIAL GEAR LUBE APPLY TUBE 35882C See step  92 - -
93 TRANSMISSION OIL CLEANER MAGNET 35394 - - -
94 TRANSAXLE HOUSING OIL SEPARATOR 35174 - - -
N.m (kgf/cm, ft.lbf): Specified torque - -
Fig 14: Automatic Transaxle Unit Reassembly Components With Torque Specifications (14 Of 18)
GTY1065378Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
95 TRANSAXLE HOUSING 35111C See step  95 - -
96 INSPECT INPUT SHAFT END PLAY - - - See step  96
*1 TRANSAXLE CASE GASKET *2 O-RING
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS - -
Fig 15: Automatic Transaxle Unit Reassembly Components With Torque Specifications (15 Of 18)
GTY1063124Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
97 TRANSMISSION REVOLUTION SENSOR (NC) 89413S - - -
98 TRANSMISSION REVOLUTION SENSOR (NT) 89413N - - -
99 FRONT OIL PUMP COVER GASKET 35313 See step  99 - -
100 TRANSAXLE CASE GASKET 35145E See step  100 - -
101 TRANSMISSION VALVE BODY ASSEMBLY 35410 See step  101 - -
102 TRANSMISSION WIRE 82125J See step  102 - -
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Toyota Genuine ATF WS - -
Fig 16: Automatic Transaxle Unit Reassembly Components With Torque Specifications (16 Of 18)
GTY1062798Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
103 TRANSMISSION CASE SIDE COVER 35151F See step  103 - -
N.m (kgf/cm, ft.lbf): Specified torque • Non-reusable part
Fig 17: Automatic Transaxle Unit Reassembly Components With Torque Specifications (17 Of 18)
GTY1062601Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
104 NO. 1 OIL COOLER OUTLET TUBE SUB-ASSEMBLY 32905 See step  104 - -
105 OIL COOLER UNION SUB-ASSEMBLY 32901C See step  105 - -
106 NO. 1 TRANSMISSION OIL FILLER TUBE 35125C See step  106 - -
107 OVERFLOW PLUG 35405C See step  107 - -
108 REFILL PLUG 35015S See step  108 - -
*1 O-RING *2 OIL COOLER UNION BOLT
*3 GASKET - -
N.m (kgf/cm, ft.lbf): Specified torque * For use with a union nut wrench
• Non-reusable part Toyota Genuine ATF WS
Fig 18: Automatic Transaxle Unit Reassembly Components With Torque Specifications (18 Of 18)
GTY1062008Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
Callout - Procedure Part Name Code
109 SHIFT CONTROL ACTUATOR BRACKET 35541A See step  109 - -
110 SHIFT CONTROL ACTUATOR ASSEMBLY 35580B See step  110 - -
N.m (kgf/cm, ft.lbf): Specified torque - -
scientia non olet · About LEMON Manuals