LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2023 >> RX 350h Base >> Repair and Diagnosis >> External Pages >> Different car >> Section 131 (Battery / Charging System - Service Information) >> Generator >> Removal [10/2022 - ] >> Procedure

Removal [10/2022 - ]: Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2025 Lexus RX 500h, 2025 Lexus RX 350, 2024 Lexus RX 500h, 2024 Lexus RX 350, and 2023 Lexus RX 500h. However, it is still accessible from the selected car via links, so may be relevant.
  1. PRECAUTION 
    NOTE:

    After the ignition switch is turned off, there may be a waiting time before disconnecting the negative (-) battery terminal.

    Refer to BEFORE DISCONNECTING BATTERY [10/2022 - ]
  2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 

    Refer to PROCEDURE - Step 2

  3. REMOVE FRONT WHEEL OPENING EXTENSION PAD LH 

    Refer to PROCEDURE - Step 9

  4. REMOVE FRONT WHEEL OPENING EXTENSION PAD RH 

    Refer to PROCEDURE - Step 10

  5. REMOVE NO. 1 ENGINE UNDER COVER 

    Refer to PROCEDURE - Step 11

  6. DRAIN COOLANT (for Intercooler) 

    Refer to PROCEDURE - Step 4

  7. REMOVE V-RIBBED BELT 

    Refer to REMOVAL [10/2022 - ]

  8. DISCONNECT NO. 2 INTERCOOLER COOLING WATER HOSE 
    1. GTY1133206Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  9. DISCONNECT NO. 3 INTERCOOLER COOLING WATER HOSE 
    1. GTY1133207Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  10. REMOVE INTERCOOLER RESERVE TANK ASSEMBLY 
    1. GTY1133208Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  11. DISCONNECT ENGINE WIRE 
    1. GTY1129773Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  12. REMOVE GENERATOR ASSEMBLY 
    1. GTY1133380Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      1. Remove the 2 nuts and bolt.
      2. Using an E8 "TORX" socket wrench, remove the stud bolt and generator assembly.
scientia non olet · About LEMON Manuals