LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2023 >> LS 500 Base, RWD >> Repair and Diagnosis >> Body & Frame >> Door Locks >> Door Lock System - Service Information >> Front Door Lock >> Removal [10/2020 - 10/2022] >> Procedure

Removal [10/2020 - 10/2022]: Procedure

  1. PRECAUTION 
    WARNING:

    Be sure to read Precaution thoroughly before servicing.

    Refer to PRECAUTION [10/2020 - 11/2021] , or refer to PRECAUTION [11/2021 - 10/2023]

    GTY824211Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    NOTE:

    After turning the engine switch off, waiting time may be required before disconnecting the cable from the negative (-) battery terminal.

    Refer to BEFORE DISCONNECTING BATTERY [10/2020 - 10/2022]

  2. REMOVE LUGGAGE COMPARTMENT MAT SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 25

  3. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 

    Refer to PROCEDURE - Step 4

    WARNING:
    • Wait at least 60 seconds after disconnecting the cable from the negative(-) battery terminal to disable the SRS system.
    • If the airbag deploys for any reason, it may cause a serious accident.
    GTY581108Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  4. REMOVE FRONT DOOR TRIM UPPER COVER LH 

    Refer to PROCEDURE - Step 4

  5. REMOVE FRONT DOOR ARMREST COVER LH 

    Refer to PROCEDURE - Step 5

  6. REMOVE FRONT DOOR NO. 2 ARMREST COVER LH 

    Refer to PROCEDURE - Step 6

  7. REMOVE FRONT DOOR TRIM BOARD SUB-ASSEMBLY LH 

    Refer to PROCEDURE - Step 7

  8. REMOVE FRONT DOOR TRIM COVER LH 

    Refer to PROCEDURE - Step 17

  9. REMOVE UPPER DOOR FRAME GARNISH LH 

    Refer to PROCEDURE - Step 18

  10. REMOVE FRONT DOOR GLASS INNER WEATHERSTRIP LH 

    Refer to PROCEDURE - Step 19

  11. REMOVE FRONT DOOR VENT SEAL LH 

    Refer to PROCEDURE - Step 20

  12. REMOVE FRONT DOOR PANEL PROTECTOR LH 

    Refer to PROCEDURE - Step 21

  13. REMOVE FRONT NO. 1 SPEAKER ASSEMBLY 

    Refer to PROCEDURE - Step 5

  14. REMOVE FRONT DOOR SERVICE HOLE COVER LH 

    Refer to PROCEDURE - Step 23

  15. REMOVE OUTER MIRROR INSTALL HOLE COVER LH 

    Refer to PROCEDURE - Step 5

  16. REMOVE FRONT MULTIPLEX NETWORK DOOR ECU LH 

    Refer to PROCEDURE - Step 25

  17. REMOVE OUTER REAR VIEW MIRROR ASSEMBLY LH 

    Refer to PROCEDURE - Step 7

  18. REMOVE DOOR SIDE AIRBAG SENSOR LH 

    Refer to PROCEDURE - Step 10

  19. REMOVE FRONT DOOR ARMREST SET BRACKET LH 

    Refer to PROCEDURE - Step 28

  20. REMOVE FRONT DOOR NO. 3 WEATHERSTRIP LH 

    Refer to PROCEDURE - Step 29

  21. REMOVE FRONT DOOR NO. 2 WEATHERSTRIP LH 

    Refer to PROCEDURE - Step 30

  22. REMOVE FRONT DOOR BELT MOULDING LH 

    Refer to PROCEDURE - Step 11

  23. REMOVE FRONT DOOR REAR BELT MOULDING END COVER LH 

    Refer to PROCEDURE - Step 32

  24. REMOVE FRONT DOOR WINDOW FRAME MOULDING LH(CENTER PILLAR SIDE) 

    Refer to PROCEDURE - Step 17

  25. REMOVE FRONT PILLAR UPPER COVER SUB-ASSEMBLY LH 

    Refer to PROCEDURE - Step 34

  26. REMOVE FRONT DOOR GLASS RUN LH 

    Refer to PROCEDURE - Step 35

  27. REMOVE FRONT DOOR FRONT GLASS RUN LH 

    Refer to PROCEDURE - Step 36

  28. REMOVE FRONT DOOR GLASS SUB-ASSEMBLY LH 

    Refer to PROCEDURE - Step 38

  29. REMOVE FRONT DOOR REAR LOWER FRAME SUB-ASSEMBLY LH 

    Refer to PROCEDURE - Step 39

  30. REMOVE FRONT DOOR NO. 2 GLASS RUN LH 

    Refer to PROCEDURE - Step 40

  31. REMOVE FRONT DOOR REAR WINDOW FRAME LH 

    Refer to PROCEDURE - Step 41

  32. REMOVE FRONT DOOR UPPER WINDOW FRAME MOULDING LH 

    Refer to PROCEDURE - Step 23

  33. REMOVE FRONT DOOR FRONT WINDOW FRAME MOULDING LH 

    Refer to PROCEDURE - Step 25

  34. REMOVE FRONT DOOR WINDOW REGULATOR ASSEMBLY LH 

    Refer to PROCEDURE - Step 44

  35. REMOVE FRONT DOOR OUTSIDE HANDLE ASSEMBLY LH (for Driver Side) 

    Refer to PROCEDURE - Step 45

  36. REMOVE FRONT DOOR LOCK CYLINDER ASSEMBLY LH (for Driver Side) 

    Refer to PROCEDURE - Step 46

  37. REMOVE FRONT DOOR LOCK WITH MOTOR ASSEMBLY LH 
    1. w/o Easy Closer:
      1. Disconnect the connector.
        GTY795325Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
        "TORX" screw
        Connector
      2. Using a T30 "TORX" socket wrench, remove the 3 TORX screws and front door lock with motor assembly LH.
        NOTE:

        Do not damage the vehicle body with front door lock with motor assembly LH.

    2. w/ Easy Closer:
      1. Disconnect the connector.
        GTY834311Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
        "TORX" screw
        Connector
      2. Using a T30 "TORX" socket wrench, remove the 3 TORX screws.
      3. Remove the 2 bolts and front door lock with motor assembly LH in the direction indicated by the arrow shown in the illustration.
        GTY816971Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
        Remove in this Direction
        NOTE:

        Do not damage the vehicle body with front door lock with motor assembly LH.

        HINT: 

        Remove the front door lock with motor assembly LH while supporting it with one hand.

    3. When reusing front door lock with motor assembly LH:
      1. Remove the door lock wire harness seal from the front door lock with motor assembly LH.
        GTY827938Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  38. REMOVE FRONT DOOR LOCK COVER SUB-ASSEMBLY LH 
    1. Using a thin-bladed screwdriver, detach the claw and open the front door lock cover sub-assembly LH.
      GTY827764Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
      Protective Tape
    2. Detach the claw and remove the front door lock cover sub-assembly LH.
      GTY778101Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  39. REMOVE FRONT DOOR LOCK REMOTE CONTROL CABLE ASSEMBLY LH 
    1. As shown in the illustration, detach the clamp and remove the front door lock remote control cable assembly LH.
      GTY784696Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
  40. REMOVE FRONT DOOR INSIDE LOCKING CABLE ASSEMBLY LH 
    1. As shown in the illustration, detach the clamp and remove the front door inside locking cable assembly LH.
      GTY791177Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
scientia non olet · About LEMON Manuals