LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2021 >> LS 500 Base, AWD >> Repair and Diagnosis >> Restraints >> Air Bag, SRS >> Supplemental Restraint System - Service Information (2 Of 4) >> Front Passenger Airbag Assembly >> Removal [10/2023 - ] >> Procedure

Removal [10/2023 - ]: Procedure

  1. PRECAUTION 
    WARNING:

    Be sure to read precaution thoroughly before servicing.

    Refer to PRECAUTION [10/2023 - ]

    GTY824211Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    NOTE:

    After the engine switch is turned off, there may be a waiting time before disconnecting the negative (-) battery terminal.

    Refer to PRECAUTION [10/2023 - ]

  2. REMOVE LUGGAGE COMPARTMENT MAT SUB-ASSEMBLY 

    Refer to PROCEDURE - Step 25

  3. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 

    Refer to PROCEDURE - Step 4

    WARNING:
    • Wait at least 60 seconds after disconnecting the cable from the negative (-) battery terminal to disable the SRS system.
    • If the airbag deploys for any reason, it may cause a serious accident.
    GTY581108Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  4. REMOVE INSTRUMENT PANEL SAFETY PAD SUB-ASSEMBLY 

    Refer to REMOVAL [10/2023 - ]

  5. REMOVE NO. 5 HEATER TO REGISTER DUCT 

    Refer to PROCEDURE - Step 1

  6. REMOVE NO. 2 SIDE DEFROSTER NOZZLE DUCT 

    Refer to PROCEDURE - Step 2

  7. REMOVE INSTRUMENT PANEL PASSENGER AIRBAG ASSEMBLY 
    WARNING:
    GTY786603Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    Deployment Side
    • When storing the instrument panel passenger airbag assembly, keep the airbag deployment side facing upward.
    • If the airbag deploys for any reason, it may cause a serious accident.
    1. Remove the 2 screws.
      GTY815280Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Insert moulding remover B, into the side of the airbag door facing the rear of the vehicle and detach the hooks.
      GTY828317Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Hold Here
    3. While holding the positions shown in the illustration, move the instrument panel passenger airbag assembly toward you, detach the hook near the front of the vehicle, and then remove the instrument panel passenger airbag assembly.
scientia non olet · About LEMON Manuals