DTC B1476: A/C Inverter Load System [07/2022 - ]: Procedure
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2024 Lexus UX 250h, 2023 Lexus UX 250h, 2022 Lexus UX 250h, 2021 Lexus UX 250h, and 2020 Lexus UX 250h. However, it is still accessible from the selected car via links, so may be relevant.
- PERFORM ACTIVE TEST USING TECHSTREAM
- Connect the Techstream to the DLC3.
- Turn the power switch on (IG).
- Turn the Techstream on.
- Enter the following menus: Powertrain / Engine / Active Test.
- Perform the Active Test according to the display on the Techstream.
Powertrain > Engine > Active Test
Tester Display Measurement Item Control Range Diagnostic Note Control the Engine Cooling Fan Duty Ratio Control the cooling fan 0 to 100% Perform this test when vehicle is stopped. Powertrain > Engine > Active Test
Tester Display Control the Engine Cooling Fan Duty Ratio OK
Cooling fan operates smoothly.
Result
Proceed to OK NG
Result:
NG
GO TO COOLING FAN SYSTEM. Refer to ON-VEHICLE INSPECTION [10/2018 - ]
Result:
OK
See step 2
- CHECK REFRIGERANT PRESSURE
- Install a manifold gauge set.
- for HFC-134a(R134a):
Refer to ON-VEHICLE INSPECTION [07/2022 - ]
- for HFO-1234yf(R1234yf):
Refer to ON-VEHICLE INSPECTION [07/2022 - ]
- for HFC-134a(R134a):
- Turn the power switch on (READY).
- Read the manifold gauge pressure when the following conditions are met.
- Prepare the vehicle according to the table below.
Item Condition Vehicle doors Fully open Temperature setting MAX COLD Blower speed HI A/C switch On Recirculation/fresh switch RECIRCULATION Interior temperature 25 to 35°C (77 to 95°F) Standard Pressure
Low pressure side
150 to 250 kPa (1.5 to 2.5 kgf/cm2 , 22 to 36 psi)
High pressure side
1370 to 1570 kPa (14 to 16 kgf/cm2 , 199 to 228 psi)
Result
Proceed to OK NG - Prepare the vehicle according to the table below.
Result:
OK
REPLACE COMPRESSOR WITH MOTOR ASSEMBLY. Refer to REMOVAL [07/2022 - ]
Result:
NG
CHARGE REFRIGERANT
for HFC-134a(R134a): Refer to REPLACEMENT [07/2022 - ]
for HFO-1234yf(R1234yf): Refer to REPLACEMENT [07/2022 - ]
- Install a manifold gauge set.