LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2020 >> LC 500 >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Door / Hatch - Service Information (Coupe) (2 Of 2) >> Luggage Door Lock Control Cable Assembly >> Removal [03/2017 - ] >> Procedure

Removal [03/2017 - ]: Procedure

  1. REMOVE NO. 1 DECK BOARD 

    See step  10 [03/2017 - 01/2021], or see step  11 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  2. REMOVE NO. 2 DECK BOARD 

    See step  11 [03/2017 - 01/2021], or see step  12 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  3. REMOVE LUGGAGE COMPARTMENT TRIM COVER LH 

    See step  12 [03/2017 - 01/2021], or see step  13 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  4. REMOVE REAR FLOOR FINISH PLATE 

    See step  15 [03/2017 - 01/2021], or see step  16 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  5. REMOVE LUGGAGE COMPARTMENT TRIM BOX 

    See step  16 [03/2017 - 01/2021], or see step  17 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  6. REMOVE NO. 1 LUGGAGE COMPARTMENT LIGHT ASSEMBLY 

    Refer to PROCEDURE - Step 1

  7. REMOVE FRONT LUGGAGE COMPARTMENT TRIM COVER 

    See step  18 [03/2017 - 01/2021], or see step  19 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  8. REMOVE INNER LUGGAGE COMPARTMENT TRIM COVER LH 

    See step  19 [03/2017 - 01/2021], or see step  20 [01/2021 - 05/2023], or refer to DISASSEMBLY [05/2023 - ] 

  9. REMOVE BACK DOOR LOCK PROTECTOR 

    Refer to PROCEDURE - Step 3

  10. REMOVE LUGGAGE COMPARTMENT DOOR LOCK ASSEMBLY 

    Refer to PROCEDURE - Step 4

  11. REMOVE REAR SEAT ASSEMBLY 

    Refer to REMOVAL [03/2017 - ]

  12. REMOVE LUGGAGE DOOR LOCK OPENER ASSEMBLY 
    1. Remove the 2 nuts and luggage door lock opener assembly.
      GTY790026Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Detach the cable clamp.
      GTY798476Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Counterclockwise Direction
    3. Turn counterclockwise direction and disconnect the cable end from the luggage door lock opener assembly.
  13. REMOVE LUGGAGE DOOR LOCK CONTROL CABLE SUB-ASSEMBLY 
    1. Roll up it partially the room partition panel insulator.
      GTY802272Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. GTY779005Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      *a Cable Clamp
      *b Clamp

      Detach the cable clamps on the room partition panel side and clamp.

    3. Detach the clamps.
      GTY830536Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    4. Detach the clamp.
      GTY790037Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    5. Detach the clamp and remove the luggage door control cable sub-assembly.
      GTY780375Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals