Data List / Active Test
- Data List
Using Techstream to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
- Warm up the engine.
- Ignition switch off.
- Connect Techstream to the DLC3.
- Turn the ignition switch to the ON position.
- Turn the tester on.
- Enter the following menus:
- for Combination Meter: Body Electrical / Combination Meter / Data List.
- for ABS/TRAC/VSC: Chassis / ABS/VSC/TRAC / Data List.
- for HV ECU: Powertrain / Engine and ECT / Data List.
- for Main Body: Body Electrical / Main Body / Data List.
- Check values by referring to the table below.
Combination Meter:
MEASUREMENT ITEM/RANGE CHARTTester Display Measurement Item/Range Normal Condition Diagnostic Note Tail Cancel SW Tail cancel switch is OFF/ON OFF: Turn the light control rheostat knob is not fully downwards - ON: Turn the light control rheostat knob fully upwards - ODO/TRIP Change SW ODO/TRIP switch is OFF/ON OFF: Switch is released - ON: Switch is pushed - Vehicle Speed Meter Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed (When driving) - Fuel Input Fuel input signal Min.: 0, Max. 127.5 Fuel gauge indicates (F): 35 - Fuel gauge indicates (3/4): 85 - Fuel gauge indicates (1/2): 145 - Fuel gauge indicates (1/4): 186 - Fuel gauge indicates (E): 205 - Rheostat value Light Control Rheostat/Min.: 0%, Max.: 100% Light control rheostat switch is Dark (0%) → Bright (100%) - ABS/VSC/TRAC:
MEASUREMENT ITEM/RANGE CHARTTester Display Measurement Item/Range Normal Condition Diagnostic Note FR/FL/RR/RL Wheel Speed Vehicle speed / Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving) - Vehicle Speed Vehicle speed / Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving) - HV ECU:
MEASUREMENT ITEM/RANGE CHARTTester Display Measurement Item/Range Normal Condition Diagnostic Note Vehicle Speed Vehicle speed / Min.: -256 km/h (-159 mph), Max.: 254 km/h (158 mph) Almost same as actual vehicle speed (When driving) - Coolant Temp Coolant temperature/ Min. :-40°C (-40°F), Max.: 140°C (284°F) After warming up: 80 to 95°C (176 to 203°F) If the value is "-40°C (-40°F) or "140°C (284°F), sensor circuit is open or shorted. Main Body (Multiplex Network Body ECU):
MEASUREMENT ITEM/RANGE CHARTTester Display Measurement Item/Range Normal Condition Diagnostic Note Open Door Warning Any door is OPEN/CLOSE ON: Any door is opened
OFF: All doors are closed- Key Unlock Warning SW Key unlock warning switch is ON/ OFF ON: Ignition key is inserted
OFF: Ignition key is not inserted- Parking Brake SW Parking brake switch is ON/ OFF ON: Parking brake is on
OFF: Parking brake is released- D Seat Buckle SW Driver seat belt buckle switch is ON/OFF ON: Seat belt is fastened
OFF: Seat belt is unfastened- Head Light SW (Head) ((1)) Headlight is ON/OFF ON: Headlight is on
OFF: Headlight is off- Head Light SW (Tail) ((2)) Taillight is ON/OFF ON: Taillight is on
OFF: Taillight is off- D Door Courtesy SW Driver door is OPEN/CLOSE ON: Driver door is closed
OFF: Driver door is opened- P Door Courtesy SW Passenger door is OPEN/CLOSE ON: Passenger door is closed
OFF: Passenger door is opened- Rear Door Courtesy SW Rear door is OPEN/CLOSE ON: Rear door is closed
OFF: Rear door is opened- (1) U.S.A. (2) Except U.S.A.
- Active Test
Using Techstream to perform Active Tests allows the relay, actuator, and other items to operate without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Test early in troubleshooting is one way to save diagnostic time. Data List information can be display while performing Active Test.
- Connect Techstream to the DLC3.
- Turn the ignition switch to the ON position.
- Turn the tester on.
- Enter the following menus: Body Electrical / Combination Meter / Active Test.
- Check the operation by referring to the table below.
Combination Meter:
CONTROL RANGE CHARTTester Display Test Part Control Range Diagnostic Note Speed Meter Operation Speedometer 0, 40, 80, 120 mph ((1)) - 0, 40, 80,120, 160, 200, 240 km/h ((2)) - Power Meter Operation Power meter gauge 0,50, 100, 150, 200 (kW) Confirm that the vehicle is stopped, engine idling Fuel Meter Operation Fuel receiver gauge EMPTY, 1/2, FULL Confirm that the vehicle is stopped, engine idling Water Temperature Meter Operation Engine coolant temperature receiver gauge Low, Normal, High Confirm that the vehicle is stopped, engine idling Meter Display 1 Multi-information display All the dots in the multi-information display OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Airbag Airbag warning light SRS warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Front Passenger Side Seat Belt Front passenger side seat belt warning light Front passenger side seat belt warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Driver Side Seat Belt Driver side seat belt warning light Driver side seat belt warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp ABS ABS warning light ABS warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Charge Charge warning light Charge warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Slip Slip indicator light Slip indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Beam Hi-beam indicator light Hi-beam indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Head ((1)) Head indicator light Head indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Tail ((2)) Tail indicator light Tail indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Fr FOG Front fog indicator light Front fog indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Driver Side Door Open Open door warning light Open door warning light is OFF/ ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Fuel Low fuel warning light Fuel level warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Tire Pressure Warning System Tire pressure warning light Tire pressure warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp ECB ECB warning light ECB warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Cruise Cruise indicator light Cruise indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Lamp Brake Brake warning light Brake warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. EPS EPS warning light EPS warning light is OFF/ON Confirm that the vehicle is stopped, engine idling Master Warning Master caution indicator light Master caution indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling Indicat. Ready (HV) Ready indicator light Ready indicator light is OFF/ON Confirm that the vehicle is stopped, engine idling (1) U.S.A. (2) Except U.S.A.