Problem Symptoms Table

WARNING: This page is about a different variant/trim than selected.

Use the table below to help you find the cause of the problem. The numbers indicate the ranked order of probability of each of the possible causes. Check each part in order. Replace parts as necessary.

MANUAL TRANSMISSION SYSTEM:

MANUAL TRANSMISSION SYSTEM DESCRIPTION

Symptom	Suspected Area	See
Abnormal noise	Oil level (Low)	MANUAL TRANSMISSION ASSEMBLY
	Oil (Wrong)	MANUAL TRANSMISSION OIL
	Gears (Worn or damaged)	MANUAL TRANSMISSION UNIT
	-	INPUT SHAFT
	-	OUTPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
	Bearings (Worn or damaged)	MANUAL TRANSMISSION UNIT
	-	INPUT SHAFT
	-	OUTPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
Oil leak	Oil level (High)	MANUAL TRANSMISSION OIL
	Gasket (Damaged)	MANUAL TRANSMISSION UNIT
	Oil seal (Worn or damaged)	MANUAL TRANSMISSION EXTENSION HOUSING OIL SEAL
	-	MANUAL TRANSMISSION ASSEMBLY
	O-ring (Worn or damaged)	MANUAL TRANSMISSION UNIT
Hard shifting or will not shift	Synchronizer ring (Worn or damaged)	INPUT SHAFT
	-	OUTPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
	Shift key spring (Damaged)	INPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
Jumps out of gear	Locking ball spring (Damaged)	MANUAL TRANSMISSION UNIT
	Shift fork (Worn)	INPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
	Gears (Worn or damaged)	MANUAL TRANSMISSION UNIT
	-	INPUT SHAFT
	-	OUTPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR
	Bearings (Worn or damaged)	MANUAL TRANSMISSION UNIT
	-	INPUT SHAFT
	-	OUTPUT SHAFT
	-	COUNTER GEAR AND REVERSE IDLER GEAR