Engine Cooling - INGENIUM I4 2.0L Petrol (G2320576)
Lubricants, Fluids, Sealers and Adhesives
NOTE:
Coolant must be collected into a clean container and can be reused if not contaminated.
| ITEM |
SPECIFICATION |
| Coolant |
Havoline Extended Life Coolant (XLC) or any glycol based engine coolant containing no methanol with only Organic Acid Technology (OAT) corrosion inhibitors |
| Coolant concentration - Will provide frost protection to -40°C (-40°F) |
50% (+10%/-0%) |
| Specific gravity of coolant at 20°C (68°F), to protect against frost down to -40°C (-40°F) |
1.068 |
CAPACITY SPECIFICATION
| INGENIUM I4 2.0L PETROL 250PS MILD HYBRID ELECTRIC VEHICLE (MHEV) |
CAPACITY IN LITERS |
| Cooling System Base (refill) |
11.45 |
| Cooling System Base (refill) with 1 auxiliary radiator |
12.25 |
| Cooling System Rear Heater + Fuel Fired Booster Heater (FFBH) (refill) with 1 auxiliary radiator |
11.65 |
| INGENIUM I4 2.0L PETROL 300PS MHEV |
CAPACITY IN LITERS |
| Cooling System Base (refill) with 1 auxiliary radiator |
12.25 |
| Cooling System Base (refill) with 2 auxiliary radiators |
13.05 |
| Cooling System Rear Heater + Fuel Fired Booster Heater (FFBH) (refill) with 1 auxiliary radiator |
12.45 |
| Cooling System Rear Heater + FFBH (refill) with 2 auxiliary radiators |
13.25 |
GENERAL SPECIFICATION
| COMPONENT TORQUE LOCATION |
 Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
|
TORQUE SPECIFICATION
| |
DESCRIPTION |
NM |
LB-FT |
LB-IN |
| 1 |
Charge air cooler screws |
7 |
- |
62 |
| 2 |
Air Conditioning (A/C) condenser bolt |
7 |
- |
62 |
| 3 |
A/C
pipes nuts |
24 |
18 |
- |
| COMPONENT TORQUE LOCATION |
 Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
|
TORQUE SPECIFICATION
| |
DESCRIPTION |
NM |
LB-FT |
LB-IN |
| 4 |
Coolant expansion tank bolt |
4.1 |
- |
36 |
| 5 |
Thermostat housing bolts |
11.5 |
8 |
- |
| COMPONENT TORQUE LOCATION |
 Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
|
TORQUE SPECIFICATION
| |
DESCRIPTION |
NM |
LB-FT |
LB-IN |
| 6 |
Coolant pump pulley bolts |
25 |
18 |
- |
| 7 |
Coolant pump bolts |
12 |
9 |
- |
| COMPONENT TORQUE LOCATION |
 Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
|
TORQUE SPECIFICATION
| |
DESCRIPTION |
NM |
LB-FT |
LB-IN |
| 8 |
Charge air cooler coolant pump bolt |
5.4 |
- |
48 |
| 9 |
Cylinder block heater |
55 |
41 |
- |
| COMPONENT TORQUE LOCATION |
 Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
|
TORQUE SPECIFICATION
| |
DESCRIPTION |
NM |
LB-FT |
LB-IN |
| 10 |
Wiring harness bracket bolt |
12 |
8.9 |
- |