Long/Stripped Engine Assembly Renew (G2357394): Notes
WARNING: This page is about a different variant/trim than selected.
PART NUMBER DESCRIPTION - ALL VEHICLES
| Name | Quantity | Part Number |
|---|---|---|
| Camshaft position sensor | 1 | LR013458 |
| Camshaft sprocket bolt | 1 | LR010530 |
| Circlip | 1 | TDL500030 |
| Coolant pump inlet O-ring seal | 1 | 1336551 |
| Crankshaft pulley bolts | 6 | 1406627 |
| Driveshaft flange bolts 1,2 | 4 | TYG500130 |
| Driveshaft flange bolts 1,2 | 6 | TYG500141 |
| EGR cooler to EGR valve gasket | 1 | LR078958 |
| Engine compartment brace bolts | 8 | LR037935 |
| Engine coolant outlet upper O-ring seal | 2 | LR018829 |
| Engine coolant pump gasket | 1 | LR079619 |
| Exhaust manifold cross-over pipe gaskets | 2 | LR072304 |
| Exhaust manifold cross-over pipe nuts | 6 | LR106277 |
| Exhaust manifold cross-over pipe studs | 6 | LR113358 |
| Exhaust manifold gasket | 2 | 1336543 |
| Exhaust manifold studs | 12 | 1357627 |
| Front halfshaft nut | 1 | LR024151 |
| Front suspension upper arm ball joint to wheel knuckle bolt(s) | 1 | KYG000230 |
| Front suspension upper arm ball joint to wheel knuckle nut(s) | 1 | FY110056 |
| Fuel injector refit kit - cylinder(s) 2, 5 or 6 | 3 | LR017437 |
| Fuel injector refit kit - cylinder(s) 3 or 4 | 2 | LR017438 |
| Fuel injector refit kit - cylinder 1 | 1 | LR017436 |
| Fuel pump drive belt kit | 1 | LR069054 |
| Fuel rail balance pipe | 1 | LR013482 |
| Intake air shutoff throttle front seal(s) | 1 | LR008353 |
| Intake air shutoff throttle rear seal(s) | 2 | 1316152 |
| Left exhaust downpipe gasket | 1 | LR016619 |
| Oil pan scavenge reservoir tube O-ring seal(s) | 1 | LR018460 |
| Oil scavenge pipe gasket | 1 | 1331076 |
| Retaining clip | 1 | 1311338 |
| Right exhaust downpipe gasket | 1 | LR016621 |
| Right fuel rail supply pipe | 1 | LR013481 |
| Shock absorber to yoke bolt | 1 | LR000094 |
| Stabilizer bar link retaining nut(s) | 1 | FY114056 |
| Steering column lower shaft lower bolt | 1 | QYG500090 |
| Tie-rod end nut | 1 | LR026275 |
| Torque converter bolts | 4 | LR038661 |
| Transmission fluid cooler tubes to transmission O-ring seals | 2 | LR049457 |
| Turbocharger coolant pipes to turbocharger gasket | 1 | LR062102 |
| Turbocharger oil feed pipe banjo bolt washers | 2 | 1372726 |
| Turbocharger oil return pipe lower gasket | 1 | LR013234 |
| Turbocharger oil return pipe upper gasket | 1 | LR013235 |
| Turbocharger oil supply pipe | 1 | LR038163 |
| Yoke to lower arm bolt(s) | 1 | LR034230 |
| Yoke to lower arm nut | 1 | LR038809 |
| Yoke to shock absorber nut(s) | 1 | FN112056 |
PART NUMBER DESCRIPTION - 17MY ONWARDS
| Name | Quantity | Part Number | VIN range from | VIN range to |
|---|---|---|---|---|
| Driveshaft flange bolts | 6 | LR092696 | HA151411 | |
| Driveshaft flange bolts | 6 | TYP500180 | HA000001 | HA151410 |
PART NUMBER DESCRIPTION - ENGINE
| Name | Quantity | Part Number | VIN range from |
|---|---|---|---|
| Engine | 1 | LR035100 | |
| Engine | 1 | LR106166 | FA000001 |
| Engine | 1 | LR048136 | |
| Engine | 1 | LR127427 | FA000001 |
PART NUMBER DESCRIPTION - SINGLE HIGH PRESSURE EGR VALVE
| Name | Quantity | Part Number |
|---|---|---|
| EGR valve outlet pipe gasket (vehicles without EGR cooler) | 1 | LR078915 |
PART NUMBER DESCRIPTION - TWIN HIGH PRESSURE EGR VALVES
| Name | Quantity | Part Number |
|---|---|---|
| EGR valve outlet pipe gasket (vehicles without EGR cooler) | 2 | LR038333 |
PART NUMBER DESCRIPTION - VIN SPECIFIC
| Name | Quantity | Part Number | VIN range from | VIN range to |
|---|---|---|---|---|
| Diesel exhaust fluid injector clamp kit | 1 | LR138592 | LA580625 | |
| Diesel exhaust fluid injector clamp kit | 1 | LR069697 | LA580624 | |
| Exhaust manifold nuts | 12 | LR004057 | JA193550 | |
| Exhaust manifold nuts | 12 | LR106277 | JA193551 | |
| Exhaust manifold to EGR valve gasket | 2 | LR031488 | FA999999 | |
| Exhaust manifold to EGR valve gasket | 2 | LR075627 | GA000001 | LR031488 |
| Flexplate bolts | 8 | 1406665 | HA146684 | |
| Flexplate bolts | 8 | LR096833 | HA146685 | |
| Left fuel rail supply pipe | 1 | LR013480 | DA999999 | |
| Left fuel rail supply pipe | 1 | LR059808 | EA000001 | |
| Secondary turbocharger oil return pipe | 1 | LR044556 | EA299999 | |
| Secondary turbocharger oil return pipe | 1 | LR044556 | FA516687 | |
| Secondary turbocharger oil return pipe | 1 | LR078522 | EA300000 | FA520408 |
| Secondary turbocharger oil return pipe | 1 | LR078522 | FA516688 | FA520408 |
| Secondary turbocharger oil return pipe | 1 | LR078875 | FA520409 | FA611880 |
| Secondary turbocharger oil return pipe | 1 | LR087351 | FA611881 | |
| Secondary turbocharger oil return pipe upper gasket | 1 | LR078880 | FA516470 | GA999999 |
| Secondary turbocharger oil return pipe upper gasket | 1 | LR087348 | HA000001 | |
| Secondary turbocharger oil return pipe upper gasket | 1 | LR013235 | FA516469 | |
| Turbocharger coolant pipe | 1 | LR061986 | FA000001 | GA110589 |
| Turbocharger coolant pipe | 1 | LR092499 | GA110590 | |
| Turbocharger coolant pipe | 1 | LR061985 | FA000001 | GA587522 |
| Turbocharger coolant pipe | 1 | LR092500 | GA587523 |