Engine Cooling - V8 S/C 5.0L Petrol: Specifications: Lubricants
NOTE:
Coolant must be collected into a clean container and can be reused if not contaminated.
| Description | Specification |
|---|---|
| Coolant | Havoline Extended Life Coolant (XLC) |
| Coolant concentration* | 50% |
* For armored vehicles that are going to be used at high speeds for extended periods of time in ambient temperatures above 48'C a ratio of 60% coolant to 40% water must be used. Failure to follow this instruction will result in poor Air Conditioning (A/C) performance.
CAPACITY SPECIFICATION
| Item | Vehicles without supercharger | Vehicles with supercharger |
|---|---|---|
| Litres | Litres | |
| Vehicles equipped with 2 zone A/C | 6.83 | 8.83 |
| Vehicles equipped with 2 zone A/C and Fuel Fired Booster Heater (FFBH) | 7 | 9 |
| Vehicles equipped with 4 zone A/C | 8.47 | 10.47 |
| Vehicles equipped with 4 zone A/C and FFBH | 8.64 | 10.64 |
TORQUE SPECIFICATION
| Description | Nm | lb-ft | lb-in |
|---|---|---|---|
| Coolant expansion tank retaining bolt | 9 | - | 80 |
| Cooling fan assembly retaining nut | 65 | 48 | - |
| Thermostat housing retaining bolts | 10 | 7 | - |
| Coolant pump retaining bolts | 12 | 9 | - |
| Accessory drive belt tensioner bolt | 48 | 35 | - |
| Radiator drain plug | 3.5 | - | 31 |
| Auxiliary radiator nut and bolt | 9 | - | 80 |
| Auxiliary radiator bolt | 5 | - | 44 |
| Auxiliary radiator nuts | 9 | - | 80 |
| Cooling fan shroud upper half screw | 4 | - | 35 |
| Transmission oil cooler to cooling fan shroud bolt | 7 | - | 62 |
| Cooling fan shroud to radiator bolt | 7 | - | 62 |
| Radiator lower bush bolt | 15 | 11 | - |
| Condenser core retainer to coolant radiator bolt | 4.5 | - | 40 |
| Refrigerant line to condenser core nut | 8 | - | 71 |
| Coolant bleed screw | 3 | - | 27 |