Torque Specification
TORQUE SPECIFICATION
| General values | Nm | lb-ft | lb-in |
|---|---|---|---|
| Air suspension compressor bolts | 10 | 7 | - |
| Air suspension compressor wiring harness ground connection bolt | 10 | 7 | - |
| Instrument panel wiring harness bracket bolt | 9 | - | 80 |
| Instrument panel wiring harness ground connection bolt | 9 | - | 80 |
| Rear bumper bracket bolt | 10 | 7 | - |
| Air duct bracket screws | 2.5 | - | 22 |
| Underfloor air duct bracket bolts | 8 | - | 71 |
| Front treadplate bracket nuts | 5 | - | 44 |
| D-pillar interior trim bracket nuts | 9 | - | 80 |
| Main wiring harness ground connection nuts | 9 | - | 80 |
| Main wiring harness loadspace bracket bolt | 8 | - | 71 |
| Side air curtain bracket bolt | 10 | 7 | - |
| Audio Amplifier Module (AAM) bolts | 10 | 7 | - |
| Infotainment Master Controller (IMC) bolt | 9 | - | 80 |
| Infotainment Slave Controller (ISC) bolts | 9 | - | 80 |
| Loadspace side trim bracket screw | 2.5 | - | 22 |
| Loadspace side trim bracket nuts | 8 | - | 71 |
| Chassis Control Module (CHCM) nuts | 8 | - | 71 |
| Body Control Module/Gateway Module (BCM/GWM) bracket nuts | 9 | - | 80 |
| Megafuse nuts | 6 | - | 53 |
| BCM/GWM nuts | 8 | - | 71 |
| Passenger Junction Box (PJB) bolt | 8 | - | 71 |
| Second row seatbelt anchor bolt | 45 | 33 | - |
| Undershield nuts | 8 | - | 71 |
| Undershield bolts | 8 | - | 71 |
| Undershield screws | 2.5 | - | 22 |
| Rear Junction Box (RJB) nut | 8 | - | 71 |
| MHEV battery cable bracket nuts | 9 | - | 80 |
| Rear subframe link wiring harness heatshield nuts | 5 | - | 44 |
| Steering column lower shaft bolt | 30 | 22 | - |
| Startup battery tray bolts | 10 | 7 | - |
TORQUE SPECIFICATION - TDV6 3.0L DIESEL
| Description - TDV6 3.0L Diesel | Nm | lb-ft | lb-in |
|---|---|---|---|
| Exhaust gas recirculation (EGR) to exhaust pipe bolt | 11 | 8 | - |
| EGR to exhaust pipe clamp | 23 | 17 | - |
| EGR cooler tube bolt | 10 | 7 | - |
| EGR outlet pipe bolt | 10 | 7 | - |
| Engine wiring harness heatshield bolt | 10 | 7 | - |
| Positive crankcase ventilation pipe bolt | 10 | 7 | - |
| Idler pulley bracket bolt | 9 | - | 80 |
TORQUE SPECIFICATION - TDV8 4.4L DIESEL
| Description - TDV8 4.4L Diesel | Nm | lb-ft | lb-in |
|---|---|---|---|
| Turbocharger low pressure (LP) hose clamp | 3.5 | - | 31 |
| Turbocharger LP hose nut | 10 | 7 | - |
| Turbocharger LP pipe bolt | 10 | 7 | - |
| Turbocharger high pressure (HP) hose clamp | 3.5 | - | 31 |
| Turbocharger HP pipe clamp | 3.5 | - | 31 |
| Turbocharger HP pipe bolt | 10 | 7 | - |
| Air Conditioning (A/C) compressor M8 bolt | 25 | 18 | - |
| Air Conditioning (A/C) compressor M10 bolt | 45 | 33 | - |
| Fuel injector heatshield nut | 10 | 7 | - |
TORQUE SPECIFICATION - V6 3.0L S/C PETROL
| Description - V6 3.0L S/C Petrol | Nm | lb-ft | lb-in |
|---|---|---|---|
| Engine wiring harness ground connection bolt | 10 | 7 | - |
| Engine wiring harness heatshield bolt | 11 | 8 | - |
| Engine wiring harness cover bolt | 10 | 7 | - |
| Thermostat housing bolt | 10 | 7 | - |
TORQUE SPECIFICATION - V8 5.0L S/C PETROL
| Description - V8 5.0L S/C Petrol | Nm | lb-ft | lb-in |
|---|---|---|---|
| Engine wiring harness ground connection bolt | 10 | 7 | - |
| Engine wiring harness heatshield bolt | 10 | 7 | - |
| Engine wiring harness cover bolt | 11 | 8 | - |
| Thermostat housing bolt | 10 | 7 | - |
| Engine coolant heater bolt | 10 | 7 | - |
TORQUE SPECIFICATION - INGENIUM I4 2.0L PETROL
| Description - Ingenium I4 2.0L Petrol | Nm | lb-ft | lb-in |
|---|---|---|---|
| Engine wiring harness bracket nuts | 9 | - | 80 |
| Engine wiring harness bracket bolts | 9 | - | 80 |
| Engine coolant pipe bolts | 10 | 7 | - |
| Engine coolant degas separator bolt | 10 | 7 | - |
TORQUE SPECIFICATION - INGENIUM I6 3.0L PETROL
| Description - Ingenium I6 3.0L Petrol | Nm | lb-ft | lb-in |
|---|---|---|---|
| Engine wiring harness ground connection bolt | 10 | 7 | - |
| Engine wiring harness bracket bolt | 10 | 7 | - |