Diesel Exhaust Fluid Tank (G1904235): Installation

WARNING: This page is about a different variant/trim than selected.

NOTE: This step is only required if previously removed.

Install the lower support bracket to the diesel exhaust fluid tank.

Torque : 7 Nm
- Install the Diesel Exhaust Fluid (DEF) tank.
- Install the DEF tank upper bolt.
  Torque : 10 Nm
- Install the DEF tank lower brackets.
  Torque : 10 Nm
Install the fuel filler pipe securing bracket.
Torque : 7 Nm
Secure the diesel exhaust fluid feed pipe to the body.
- Connect the wiring harness to the DEF pump.
- Secure the wiring harness.
Connect the DEF feed pipe.
- Remove the fuel filler cap.
- Remove the DEF filler cap.
CAUTION: Make sure that the lip of the seal is correctly located.

Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

Install the filler cap surround.
- Install the fuel filler cap.
- Install the DEF filler cap.
NOTE:
- This step is only required if a new component is installed.
- DEF Tank comes as an assembly with DEF Injection Pump, if a new DEF Tank is installed make sure to configure the new DEF injection pump.
- Connect the Jaguar Land Rover (JLR) approved diagnostic equipment.
  General Equipment: Jaguar Land Rover approved diagnostic equipment
- Select 'Powertrain - Diesel exhaust fluid injection pump replacement' from the diagnostic menu.
- Make sure that all steps from the on-screen instructions are followed.
Fill the diesel exhaust fluid tank.
Refer to: DIESEL EXHAUST FLUID TANK DRAIN AND REFILL