LEMON Manuals: Even more car manuals for everyone
Home >> Land Rover >> 2015 >> Range Rover Autobiography >> Repair and Diagnosis >> External Pages >> Different car >> Section 1 (Fuel Charging & Controls - V8 S/C 5.0L Petrol -- Range Rover/L405) >> Fuel Charging And Controls - V8 S/C 5.0L Petrol >> Left Fuel Rail >> Removal And Installation >> Removal

Removal And Installation: Removal

WARNING: This page is about a different car, the 2018 Land Rover Range Rover, 2017 Land Rover Range Rover, 2016 Land Rover Range Rover, 2014 Land Rover Range Rover, and 2013 Land Rover Range Rover. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Make sure that tools and equipment are clean and free of foreign material and lubricant.
NOTE: Some variation in the illustrations may occur, but the essential information is always correct.
  1. Refer to: PETROL AND PETROL-ETHANOL FUEL SYSTEMS HEALTH AND SAFETY PRECAUTIONS .
  2. Refer to the appropriate Fuel System Pressure Release service information.
  3. Disconnect the battery ground cable.

    Refer to: SPECIFICATIONS .

  4. Refer to: FUEL INJECTION COMPONENT CLEANING .
  5. Refer to: AIR CLEANER OUTLET PIPE T-CONNECTOR .
  6. CAUTION: Be prepared to collect escaping fluids.
    G11689196
  7. CAUTION: Be prepared to collect escaping fluids.
    G11689197
  8. CAUTION: Be prepared to collect escaping fluids.
    G11607319
  9. G11687513
  10. G11607545
  11. WARNING: Do not smoke or carry lighted tobacco or open flame of any type when working on or near any fuel related components. Highly flammable vapors are always present and may ignite. Failure to follow these instructions may result in personal injury.
    CAUTION: Make sure that the fuel line union does not rotate.
    G11770419
  12. G11688955
  13. G11688956
  14. CAUTION: Make a note of the fuel injector clamp alignment to the fuel rail prior to removal.
    G11688958
  15. CAUTION: Make sure that the special tool is located correctly to the fuel injector prior to removing the fuel injector.
    NOTE: RH illustration shown, LH is similar.
    G11607550

    Special Tool(s): 310-197 

  16. CAUTION: If new fuel injectors are installed, a new injector clamp must be installed.
    G11587674
  17. CAUTION: Do not use a knife to remove the Teflon seal as damage could occur to the fuel injector.
    G11607552
  18. CAUTION: Do not use any sharp tools to remove the O-ring seal as damage could occur to the fuel injector.
    G11607553
scientia non olet · About LEMON Manuals