General Procedures: Adjustment

WARNING: This page is about a different car, the 2018 Land Rover Range Rover, 2017 Land Rover Range Rover, and 2016 Land Rover Range Rover. However, it is still accessible from the selected car via links, so may be relevant.

CAUTION: Extreme cleanliness must be exercised when handling these components.

NOTE: Make sure to add 1 liter of fluid to the upper tank and drain it through the clear hose, if the Diesel Exhaust Fluid (DEF) dispensing kit is being used for the first time.

CAUTION: Failure to carry out this instruction may cause damage to the vehicle.

Check the quality of the diesel exhaust fluid within the diesel exhaust fluid dispensing kit using a hydrometer.

General Equipment: Diesel Exhaust Fluid (DEF) quality hydrometer
WARNING: Failure to carry out this instruction may result in personal injury.

Make sure the operating levers of the diesel exhaust fluid dispensing kit are in the positions indicated.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
CAUTION: Make sure that the diesel exhaust fluid dispensing kit flow meter is reset.
CAUTION: Make sure that the upper tank is not overfilled. Observe at all times.

Fill the upper tank to the correct amount of diesel exhaust fluid, previously specified by the Land Rover approved diagnostic equipment.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
CAUTION: Failure to carry out this instruction may cause damage to the vehicle.

Make sure that the inner rubber feed hose is in the position shown.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
Remove the diesel exhaust fluid filler cap.
CAUTION: Make sure the diesel exhaust fluid dispensing kit is correctly installed onto the diesel exhaust fluid filler pipe.

Install the diesel exhaust fluid dispensing kit on to the diesel exhaust fluid filler pipe.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
NOTE: Fluid may be visible in the outer hose.

Position the diesel exhaust fluid dispensing kit upper operating lever to the position indicated. The diesel exhaust fluid tank top-up procedure will now commence. Immediately proceed to the next step.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
- Fill the vehicle with the correct amount of diesel exhaust fluid specified by Land Rover approved diagnostic equipment.
- When the correct amount has been drained, position the diesel exhaust fluid dispensing kit upper operating lever in the position indicated.
  General Equipment: Diesel Exhaust Fluid Dispensing Kit
1. Position the diesel exhaust fluid dispensing kit lower operating lever in the position indicated.
2. Operate the pump on the diesel exhaust fluid dispensing kit to recover any diesel exhaust fluid remaining in the clear filler pipe. The diesel exhaust fluid is recovered through the inner pipe at the vehicle filler pipe. The pipe may need to be raised to assist recovery.
  General Equipment: Diesel Exhaust Fluid Dispensing Kit
NOTE: Make sure the pump on the diesel exhaust fluid dispensing kit is switched off before this step is carried out.

Position the diesel exhaust fluid dispensing kit lower operating lever to the position indicated.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
Using the Land Rover approved diagnostic equipment, follow the on-screen instructions and check the diesel exhaust fluid level.
General Equipment: Land Rover diagnostic equipment
CAUTION: If any fluid remains in the clear filler pipe after the diesel exhaust dispensing kit is disconnected from the vehicle, this must be drained and discarded before the equipment can be used again.

Disconnect the diesel exhaust fluid dispensing kit from the diesel exhaust fluid filler pipe.

General Equipment: Diesel Exhaust Fluid Dispensing Kit
CAUTION: Make sure that the mating faces are clean and free of foreign material.

Install the diesel exhaust fluid filler cap until an audible click is heard 3 times.