LEMON Manuals: Even more car manuals for everyone
Home >> Kia >> 2020 >> Soul GT Line Turbo >> Repair and Diagnosis >> External Pages >> Different car >> Section 62 (Maintenance) >> Power Train >> Transmission Gear Oil (IVT) >> Repair Procedures >> Inspection >> Intelligent Variable Transmission Fluid (IVTF) Level Check

Intelligent Variable Transmission Fluid (IVTF) Level Check

WARNING: This page is about a different car, the 2021 Kia Soul. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: When checking the IVTF level, be careful not to allow foreign substance (like dust) to enter through the filler hole.
  1. Remove the air duct and air cleaner assembly.

    G 1.6 T-GDI GAMMA (Refer to Engine Mechanical System - "AIR CLEANER ")

    G 2.0 MPI NU(ATKINSON) (Refer to Engine Mechanical System - "AIR CLEANER ")

  2. Add 0.3 liters of SP-CVT1 through the IVTF filler hole after removing the IVTF injection plug (A).
    G13280224Courtesy of KIA MOTORS AMERICA, INC.
  3. Start the engine to warm up the IVTF.
    NOTE: Do not step on the brake and accelerator simultaneously to warm up the IVTF.
  4. Check by using KDS that the temperature of the IVTF is between 50°C and 60°C (122 - 140°F).
  5. Move the shift lever slowly from "P" to "D", then back to "P". Repeat this sequence two times and then move the shift lever to "P" range.
    NOTE: Maintain at each speed position for more than 2 sec.
  6. Remove the engine room under cover.

    G 1.6 T-GDI GAMMA (Refer to Engine and Transmission Assembly - "ENGINE ROOM UNDER COVER ")

    G 2.0 MPI NU(ATKINSON) (Refer to Engine and Transmission Assembly - "ENGINE ROOM UNDER COVER ")

  7. Lift the vehicle and remove the IVTF level plug (A) from the valve body cover.
    NOTE: When removing the IVTF level plug, keep the vehicle on a level ground.
    G13280225Courtesy of KIA MOTORS AMERICA, INC.
  8. Check the IVTF level.

    Normal:  IVTF flows out in a thin oil stream.

    Excessive (abnormal):  Over 0.4 liters of IVTF flows out for 2 minutes.

    Insufficient (abnormal):  There is no fluid flow.

    NOTE: If the IVTF level is too high or low, follow the instructions below.
    • Excessive: Drain until the IVTF flows out in a thin oil stream.
    • Insufficient: Add until the IVTF flows out in a thin oil stream.
  9. Install the IVTF level plug (A).

    Tightening torque: 

    34.3 - 44.1 N.m (3.5 - 4.5 kgf.m, 25.3 - 32.5 lb.ft)

    G13280226Courtesy of KIA MOTORS AMERICA, INC.
  10. Lower the vehicle and install the IVTF injection plug (A).

    Tightening torque: 

    34.3 - 44.1 N.m (3.5 - 4.5 kgf.m, 25.3 - 32.5 lb.ft)

    G13280227Courtesy of KIA MOTORS AMERICA, INC.
scientia non olet · About LEMON Manuals