Repair Procedures: Inspection: Notes

Check point (Warning indicator)

NOTE: For fault conditions and normal operating conditions, refer to the owner's manual.

NO	Ref Symbol	Name	Color	Signal input	Signal Control	Check point
1	Courtesy of KIA MOTORS AMERICA, INC.	Turn signal (Left)	Green	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
2	Courtesy of KIA MOTORS AMERICA, INC.	Turn signal (Right)	Green	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
3	Courtesy of KIA MOTORS AMERICA, INC.	Tail Lamp	Green	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
4	Courtesy of KIA MOTORS AMERICA, INC.	Front Fog Lamp	Green	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
5	Courtesy of KIA MOTORS AMERICA, INC.	Rear Fog Lamp	Yellow	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
6	Courtesy of KIA MOTORS AMERICA, INC.	High Beam	Blue	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
7	Courtesy of KIA MOTORS AMERICA, INC.	Low Beam	Green	CAN	IBU (Gateway)	Multifunction Switch IBU CAN Failure
8	Courtesy of KIA MOTORS AMERICA, INC.	HBA	Green	CAN	LDW	LDW System CAN Failure
9	Courtesy of KIA MOTORS AMERICA, INC.	Warning	Yellow	CAN	BSD	BSD System CAN Failure
					TPMS	TPMS System CAN Failure
					SCC	SCC System CAN Failure
					LDW	LDW System CAN Failure
					FCW	FCW System CAN Failure
					HBA	BSD System CAN Failure
					IBU	Exterior Lamp IBU CAN Failure
				Hard-wired	Low Washer	Washer fluid lever sensor Wiring Failure
				Hard-wired	Digital Input	Reminder for service checks
10	Courtesy of KIA MOTORS AMERICA, INC.	Battery Charge	Red	Hard-wired	Alternator	Alternator Wiring Failure Battery
11	Courtesy of KIA MOTORS AMERICA, INC.	Oil Pressure	Red	Hard-wired	ECM	Oil Pressure Sensor Wiring Failure ECM CAN Failure
12	Courtesy of KIA MOTORS AMERICA, INC.	Check Engine	Yellow	CAN	ECM	ECM CAN Failure
13	Courtesy of KIA MOTORS AMERICA, INC.	Immobilizer	Yellow	CAN + Hard-wired	IMMOBILIZER SMK	Immobilzer System SMK IBU CAN Failure Hard-wired
14	Courtesy of KIA MOTORS AMERICA, INC.	ABS	Yellow	CAN	ABS	ABS System CAN Failure
15	Courtesy of KIA MOTORS AMERICA, INC.	ESC	Yellow	CAN	TCS	TCS System CAN Failure
16	Courtesy of KIA MOTORS AMERICA, INC.	ESC Off	Yellow	CAN	TCS	TCS System CAN Failure
17	Courtesy of KIA MOTORS AMERICA, INC.	EPB	Yellow	CAN	EPB	EPB System CAN Failure
18	Courtesy of KIA MOTORS AMERICA, INC.	Auto Hold	White Yellow Green	CAN	TCS	TCS System CAN Failure
19	Courtesy of KIA MOTORS AMERICA, INC.	Seat Belt	Red	CAN	IBU (Gateway)	IBU CAN Failure
20	Courtesy of KIA MOTORS AMERICA, INC.	Airbag	Red	CAN	SRSCM	SRSCM System CAN Failure
21	Courtesy of KIA MOTORS AMERICA, INC.	EPS (MDPS)	Red	CAN	MDPS	MDPS Unit System MDPS Motor CAN Failure
22	Courtesy of KIA MOTORS AMERICA, INC.	LED Headlamp	Yellow	CAN	AFL	AFL System CAN Failure
23	Courtesy of KIA MOTORS AMERICA, INC.	TPMS	Yellow	CAN	TPMS	TPMS System TPMS Sensor CAN Failure
24	Courtesy of KIA MOTORS AMERICA, INC.	LDW	Green Yellow White	CAN	LDW	LDW System CAN Failure
25	Courtesy of KIA MOTORS AMERICA, INC.	Fuel Warning	Yellow	Direct (Micom)	Fuel Sender	Fuel Sender Failure Wiring Failure
26	Courtesy of KIA MOTORS AMERICA, INC.	AEB	Yellow	CAN	SCC	AEB System CAN Failure
27	Courtesy of KIA MOTORS AMERICA, INC.KIA MOTORS AMERICA, INC. Courtesy of KIA MOTORS AMERICA, INC.KIA MOTORS AMERICA, INC.	AUTO STOP	Green Yellow	CAN	ECM	ECM CAN Failure
28	Courtesy of KIA MOTORS AMERICA, INC.	Over Speed Warning	Yellow	CAN	ABS TCS (Speed)	ABS System TCS System CAN Failure
29	Courtesy of KIA MOTORS AMERICA, INC.	4WD	Yellow	CAN	4WD	4WD ECU Can Failure

Check point (Gauge)

NO	Name	Signal Input	Signal Control (Unit/Sensor)	Check Point
1	Speedometer	C-CAN	ABS/ESC	1) CAN Line failure
2	Tachometer	C-CAN	EMS	1) CAN Line failure
3	Cooling water temperature	C-CAN	EMS	1) CAN Line failure
4	Fuel	Hardwire	Fuel Sender	1) Fuel sender failure
4	Fuel	Hardwire	Fuel Sender	2) Wiring failure