Body (Interior & Exterior) - General Information: Troubleshooting
PROBLEM SYMPTOMS
| Symptom | Suspect Area | Remedy |
|---|---|---|
| Water leaks from sunroof | Dirt accumulated in drain tube | Clear dirt inside of drain |
| Clogged drain tube | Blow air into drain to remove dirt | |
| Broken or dislocated drain tube, defective Or cracked clip | Check tube installation and Flange contact | |
| Deteriorated roof lid weatherstrip | Replace | |
| Excessive roof lid-to-body clearance and Improperly fitted weatherstrip | Adjust | |
| Wind noise around sunroof | Loose or deformed deflector, gaps In body work | Retighten adjust or replace |
| Sunroof lid makes a noise when moving | Foreign particles lodged in guide rail | Check drive cable and guide Rails for foreign particles |
| Loose guide rails and lid | Retighten | |
| Motor runs but sunroof does not move or moves only partially | Foreign particles lodged in guide rail | Check drive cable and guide Rails for foreign particles |
| Incorrect engagement of motor pinion With drive cable | Check for loose motor installation And damaged pinion | |
| Decrease in motor's clutch slipping force | Adjust | |
| Increased sunroof sliding resistance Or interference of sunroof with drive cables, weatherstrip, etc. due to maladjustment of sunroof | Adjust or replace | |
| Noise in motor (clutch slipping Noise from motor when sunroof Is fully opened or closed is not An unusual noise | Incorrect engagement of motor pinion With drive cable | Check pinion installation and Retighten motor |
| Worn out or damaged motor pinion bearing | Replace motor assembly | |
| Worn out or deformed drive cable | Replace | |
| Door glass fails to operate Up and down | Incorrect window glass installation | Adjust position |
| Damaged or faulty regulator arm or regulator | Correct or replace | |
| Door does not open or close completely | Incorrect door installation | Adjust position |
| Defective door check assembly | Correct or replace | |
| Door hinge requires grease | Apply grease | |
| Hood does not open or close completely | Striker and latch not properly aligned | Adjust |
| Incorrectly installed hood | Adjust | |
| Incorrect hood bumper height | Adjust | |
| Water leak through windshield end rear window | Defective seal | Fill with sealant |
| Defective flange | Correct |